Table 1 shows one common steering related problems of the 2022 Ford Explorer.
| Problem Category | Number of Problems |
|---|---|
| Steering problems |
The rack and pinion system needs to be replaced as a result of "normal wear and tear".
While traveling on I-26 east near north carolina mm 51 in the left lane, the vehicle suddenly pulled uncontrollably to the left resulting in a sideswipe of the guardrail. The vehicle then swerved to the right stopping near the center of the interstate. My wife was able to move the vehicle to the right shoulder under its own power. The right front tire/wheel was laying almost flat attached to the vehicle only by the brake line. The entire wheel assembly was detached from the steering/suspension system. The vehicle was towed to a local collision center and inspected by my insurance adjuster. The vehicle was determined a total loss. There were no injuries or other vehicles involved. The nc highway patrol responded but did not complete an accident report.
Ongoing issues with the screen displaying upside down, blurry, red/green lines, powering on and completely off. Rearview calibration issue off centered (dealership fixed). This also impacts the cruise control alerts, lane keeping assist, etc. And occasionally powers vehicle off. Dealership was able to fix delayed reverse transmission via software for the pcm. Multiple dealership repair attempts have not fixed this ongoing issue from 2022-2025. Videos available via email request. Dealership verified some of the concerns and Ford would only authorize software updates, new battery, some camera components. When this failed to fix they were not authorized to further repair. As a courtesy the dealership rebuilt the software and this did not fix the issues.
Driver assist warning light comes on and I lose power steering on my Ford. I took the vehicle in last month for repair. Dealer said it was a software issue. Rest the software. This did not fix issue. I was driving on highway at 65 miles when steering assist message popped up and I lost my power steering. This a major safety issue. I checked on line and other drivers had reported the same issue. Please advise.
As you drive and pick up speed at the range of 29 to 31 mph, exactly the car shutters and shakes. It is known by Ford that the driveshaft needs to be angled due to the hybrid battery location in the car. This particular problem is consistent with a driveshaft replacement that has been known by Ford as well as bearings in the driveshaft. I have had problems with the shuttering in this vehicle almost since day, one of owning it.
The contact owns a 2022 Ford Explorer. The contact stated that while reversing, the vehicle steering wheel seized. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 10,000.
The contact owns a 2022 Ford Explorer. The contact stated while starting the vehicle, the steering wheel started moving independently from side to side, without warning. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was 207,000.
The steering wheel moves back and forth by it's self.
Vehicle's steering wheel moves by it's self.