general problems of the 2016 Ford F-150 - part 2

When fueling the Ford f 150, it will not shut off almost all fuel handles and as a result gasoline spews out a couple feet past the fuel pump handle as well as spilling fuel all over the side of the truck. This poses a fire hazard as well as slipping and carcinogen issue. Also, the paint and tires are subjected to deterioration and the vehicle smells of fuel for some time afterwards. I can never completely fill the vehicle without putting my ear up to the truck fill tube. No matter how far back I jump, I always get fuel on my feet, shoes and clothing. I haven't had fuel get in my eyes yet, but it is just a matter of time. Maybe a fuel station has already blown up. I'm sure that won't bee long if it has not already happened.

Stalls at when at idol at stop lights. Mechanics can't find out why. No warnings lights in cash come on.

Unknown gas mileage has plummeted from 19mpg highway/city down to 12. 5mpg highway/city hard starting is random so very hard to catch for auto mechanics, new spark plugs, no check engine lights, multiple mechanics both dealership and 3rd party cannot find anything wrong with the truck fuel pump tested and is fine, O2 sensor either working properly or not telling the computer something is wrong gas mileage suddenly plummeted with no reason, nothing is telling the computer anything is wrong and nobody can find out why my gas mileage has plummeted so drastically with no signs of bad or faulty parts.

Driving down interstate 80 at 70mph and track assist error, then hill start assist unavailable error, wrench light (see manual), engine light. I depress the gas pedal and there is no response, the engine rpm does not increase. I have to pull off to the side of the interstate, towing a boat, luckily not in construction zone ahead with concrete barriers on both sides. Turn off and restart, the engine / rpm still do not respond. Turned off for 5 minutes while I make a call. Turn on again and rough idle but the engine responds and I am able to drive the remaining 15 miles to home. Exact thing happened again 4 days later on 2 lane, hilly, country highway without a shoulder. I stopped in the road, hazards on, turned off/on again, didn't respond to gas. Wait 5 minutes turned on again and was able to get to home.

Vehicle lost acceleration on interstate highway multiple times and caused dangerous maneuvers to avoid collision. Ford has acknowledged issue via consumer satisfaction 16b32 but I was never mailed any notification. This must be a recall. This is the most dangerous event I have experienced driving.

Truck will stall/shut off at a stop while towing. Red battery light will show on dashboard. Car will turn over then shut down again by itself within a few seconds. This happened 3 times at this point- once while in gas station in line to get gas (stationary) once at intersection (stationary at stop light), another time after stopping vehicle to get gas. At first event 30 minutes after it not working a jump started the vehicle successfully, at second instance jump would not start car, had to get towed, at third instance we were able to start vehicle by holding throttle down while putting in drive. Brought to Ford dealership- said nothing was wrong, would not work on truck, said no computer codes were found.

Engine stalls (at low rpms) mostly when stopping at traffic lights, not as bad if im able to put in park (it will still idle rough. But, not as likely to completely stall). I have noticed this is more likely after driving at higher speeds (70mph - 85mph) for prolonged periods of time (1hr - 6hrs). I bought the truck 4yrs ago, with 78k on it.

On 9/6/2020, while driving approx 60mph on hwy 128 between jal and carlsbad nm, the brake pedal on my 2016 Ford f150 lariat went to the floor and I had no brakes. A message on my dash came up saying to add brake fluid and I did. I took my truck to the nearest dealership, carslbad Ford Lincoln. The master cylinder and booster had a recall and was replaced, but the brake fluid that leaked into the engine was never addressed by the service and repair center. As a result, I now have over $6,000 worth of collateral damage to my engine that the dealership is refusing to fix because I'm being blamed for the damages for adding brake fluid to the resevoir. It's beyond obvious that the only way any brake fluid leaked into the engine was due to the damaged manufacturer part(s), the master cylinder and the booster, that were not only damaged but in recall status - recall# 20s31. The gm and service manager of the carslbad Ford Lincoln dealership have the power, the support and backing of a behemoth. They have the full support of the great american auto giant Ford motor company and I have 100% nothing and nobody! there has to be some law or some thing to protect your everyday innocent tax paying american citizen from being taken advantage of by people who work for these powerful entites and/or companies. I'm writing this complaint on 9/27 and they've had my truck since 9/12; just over two weeks. I'm issuing this complaint because I literally cannot pay for the $6,212 worth of repairs that Ford motor CO is accountable and responsible for. Also, with (2) blown turbo chargers, tube asy, converter asy, sensors etc which all need to be replaced; my truck is not safe for me to drive and other citizens communting with or without their families on american highways shouldn't be subjected to this unsafe vehicle being on the road.

Vehicle suddenly lost power while driving both from a stop and at highway speeds. I shut off vehicle and restarted it which seemed to temporarily solve the problem only to have it reoccur days later. Engine code registered on the dash display. Code was retrieved (p2112) which correlates to a faulty throttle body. Ford has acknowledged this problem with an extended warranty replacement, but my local dealership will not replace the throttle body, so I was forced to replace it myself and pay for the faulty part. My vehicle had less than 36,000 miles at the time of this incident. When the vehicle loses power in traffic, it is definitely a life, health, safety issue. There are numerous examples that can be found on the internet of this defective part/throttle body on various Ford vehicles. I feel that Ford should initiate a recall for obvious safety reasons. Ford has put out various TSB's regarding this documented problem.

While driving on a highway on 8/30/20, the truck experienced a complete loss of forward motion, began "bucking" and codes and warnings started appearing on the dashboard. Were able initially to coast to a safer location to stop. Truck would not move although the engine was running. Turned the truck off, restarted and all codes disappeared. However, as soon as we started again, within a quarter mile, same failure occurred. In 20 miles, this happened approximately 6 more times and we could not get safely off the road (no shoulders with ditch on side) having to come to a complete stop, turn engine off and restart the vehicle while in the traffic lane. Very unsafe and we were lucky not to be hit by passing vehicles. After researching what this possible could be, found it likely that it was a failure of the electronic throttle body, which was the subject of a recall in previous year models of this vehicle as well as a customer satisfaction action #16b32 for replacement of the electronic throttle body for our year of manufacture. (our truck was manufactured in dearborn during the period that this action was to be taken 8/1/15 through 5/17/16. ) made appointment at local dealer and our truck was serviced yesterday at pittsville Ford in pittsville MD and the diagnosis was the electronic throttle body failure. The etb and gasket were replaced at a cost to us of $551. 14. I have seen online threads of others having this same failure and want to know why ours was not part of a recall or other, longer customer satisfaction action, as this could have caused a severe or even fatal accident. Very dangerous to have this type of catastrophic failure with no warning at all. I have reported this issue for Ford and my questions regarding why this was not already replaced and have been assigned a case number - cas-27541116. Told our VIN was not a part of this action. How?.

Related to TSB-16-0139. While driving: hill start assist unavailable message; service advancetrac message. Wrench icon, traction icon, and check engine icon displayed. Truck went into limp mode. Rough idle, would not accelerate until turned off and back on. Dealership diagnosed to replace throttle bodies. Would not cover under extended warranty I believe there may have been a recall on some f150s, but it didn't include my month/year of manufacture, to the best of my knowledge.

I was recently pulling a travel trailer down a mountain pass with my 2016 f150 with the 3. 5l ecoboost engine. The vehicle went into limp mode losing power to the motor, the travel trailer started �fish tailing�!! the 2 vehicles behind me locked up their brakes (could visibly see smoke), the third vehicle was slower to react and pulled out and passed all 3 of us narrowly avoiding a head on collision! I took the truck to the service shop and it was determined to be the throttle body and it was replaced. . . . For the 4th time in 94,000 miles!!! the previous 2 times this happened to me the same problem occurred (vehicle went into limp mode), but those times I was driving 75mph down a 5 lane freeway and had to crossover 5 lanes of traffic with no power to my engine! vehicles swerving everywhere, people locking up their brakes. . . . Minor miracle there were no accidents. I've filed complaints to Ford on each occasion and they've done nothing about it! it's a common, well known problem that Ford is aware of and somebody is eventually going to die because of this issue! asking for help!.

I was driving down the road and engine lost complete power, but the engine was still running. I was able to get off the road and shut the engine off and restart it. This happened again a couple of weeks later. I called the Ford dealer on Saturday and was informed that it was probably a throttle body issue. I was able to get an appointment on Monday, but this problem occurred again about 10 times over the weekend. In my opinion this should be a safety recall as this issue could occur while passing on a narrow tow lane road, going through an intersection, crossing a railroad track, etc. ,. From an internet research I I found that Ford has issued TSB 16-0139 on October 10, 2016 and there were numerous comments from others having the same problem. In fact the maintenance manager at Ford told me this had happened to him twice.

My 2016 Ford f150 with engine block heater caught fire today 14 February 2020 at 11:12 am. It was moving and caught fire when I parked the truck.

Highway driving at 55 mph, ding and message "service advancetrac", "hill start assist not available". Throttle unresponsive and truck immediately begins slowing. Managed to get off road without an accident. Engine running roughly in idle. Turn engine off and restart. Operates normally. This has occurred 3 times and puts the vehicle and passengers in an extremely unsafe position! internet research indicates that this is a common issue with Ford throttle bodies. Ford company and dealership refuse to acknowledge that this is a common problem. Trouble code shows p2112.

I was operating my 2016 Ford f150 on a secondary gravel rd at 30 mph in 2wd. Upon going a slight uphill grade, the vehicle lost all acceleration and came to a stop idling roughly at 1000 rpm. The wrench light, hill decent and traction control warning light illuminated. The engine idled but would not accelerate. I shut off the engine and restarted it. This seemed to correct the problem clearing the error codes. However, continuing on the road, the same problem occurred 3 miles later. I was in a remote area in the state and had to travel 60 miles to a urban area. This problem occurred at least 20 more times with greater frequency until arriving at my residence. The vehicle was repaired by the Ford dealership in sheridan, wy. The fix was as follows. Diag, p2112-throttle actuator a control system, stuck closed, pinpoint to throttle body. Replaced throttle body, cleared codes. My vehicle had 38,450 miles when this incident occurred on October 17, 2019, 4:30 pm. After doing some research with other Ford f150 owners, this appears to be a prominent problem and in my mind, a dangerous one. Most of the incidences appear to happen in the similar mileage range but in other model years, 2017 and 2018 were prevalent also. The Ford service manager related he had done allot of these repairs recently. Their is no recall for this issue at this time.

While using my vehicle under normal conditions the check engine light came on so I had vehicle checked at autozone and o'reily's which showed 2 different codes and took it to machaik dealership. Turns out I had to have both cylinder heads replace, crankshaft bolt replaced as well as a few other items. I was told it was an issue that Ford was aware of and didn't notify me of it when I bout the vehicle. They covered the cost due to the vehicle being under warranty which was about $5,000. $ months later I got my vehicle back and about 30 miles of driving 55mph it started blowing a thick cloud of white smoke with some grey smoke. I take the vehicle home and let it sit for 28 days before I have to use it and after about 23 miles it started smoking again. I take it to the same dealership again and I told them about the smoking issue, rough idle and the exhaust smells like gas which is not normal. I showed them a video of the issue which contains my mileage at the time and my license plate which clearly shows my vehicle so they cannot say it wasn't my vehicle. Waiting for the results of their findings and plan to update the complaint. I will not upload the video at this time due to it containing my license plate, don't know how to upload it from phone and I don't know how to edit that out. If it is necessary to update this complaint I will upload the video as proof as well as work order from previous and current work. My mileage will not be 100% accurate but it will be within 400 miles plus or minus.

Behavior matches the issues described in Ford recall 16b32. When I accelerate the vehicle the engine occasionally stops accelerating and goes into a failure mode where I cannot accelerate. A few warnings show up on the dashboard related to hill start assist and being disabled and to service advance track. Turning the car off and back on resolves the problem, but this is very dangerous as I'm usually accelerating to get onto a highway where it's not safe to have my vehicle stop. From the description of the recall my vehicle should be included in 16b32 (manufactured between 8/31/15 to 4/27/16 in kansas city), but Ford tells me my VIN is not listed as affected. This problem has occurred twice now and it is unpredictable in when it will occur. A quick google search of "hill start assist failure" shows a large number of other Ford owners with the exact same problem.

My vehicle was in motion at approximately 65 mph when it suddenly entered a limp mode, indicated by multiple dash warning lights and an abrupt loss of power. The vehicle was incredibly unsafe to operate in such condition. Ford has a known problem with the electronic throttle body used on these motors, but has failed to issue a recall on a part that could cause great bodily harm and injury if it should fail in heavy traffic scenarios.

My truck lost complete power on 8/3/19. Several different waning lights came on. Fortunatley, I was lost power on a straight stretch of road at about 30 mph. I was able to "limp" my truck back home. I have a code reader and it showed code p2112 "throttle actuator control system stuck closed". I searched online and found a Ford customer service letter from 2016-2017 addressing this issue with an expiration notice of September 2017. I purchased the vehicle used in December 2016 and was never sent any notice. I find it incredible that Ford knows about a defect that causes a vehicle to lose power suddenly, and addresses it with this bandaid level of service. It is a simple and inexpensive fix. I fixed it myself in less than an hour with a part purchased from Ford that was less than $200. My concern is that Ford did not notify me and will not stand by this dangerous defective issue. They have told me there was an expiration on that letter and they will not help me. Please force them to do an actual recall on this issue before someone is killed! thank you for your time.

Instrument panel lights up with various fault messages related to traction control, downhill descent, etc. . . Within seconds the vehicle begins to stutter, fails to respond to attempts to accelerate by pressing gas peddle, and eventually loses power. Happened twice while travelling at highway speeds resulting in a dangerous scenario of pulling to the side of the highway.

Reported my issue already 11229377 but wanted to point out that at a quick glance there are another 30+ NHTSA safety complaints for my same issue. 11022233, 10955596, 11174190, 10870553, 10887486, 11165975, 11150176, 11139022, 11101604, 11048673, 1102997, 11174190 to name a few. Ford has also issues several TSB and ssm for this issue. Tsb16-0139, tsb17-2124, ssm46829, tsb16b23-s1. At what point does NHTSA put pressure on Ford to resolve these issues? will it require a death to be associated to this issue? a fire, accidents? there are also countless online forum posts on this issue. I can find numerous links showing this but I think the sheer number of complaints on here coupled with warranty numbers for this issue should be sufficient to open an investigation. I plan to write a letter to my local news outlets and governor.

It idles rough at stop light sometimes shuts down ,radio screen is blank sometimes w radio or phone call. Electrical burning smell enough to make me nauseous. The computer reads no codes. This happens every couple of days, it has been at 2 different shops up to weeks at a time they have changed several parts but none have fixed it.

I just purchased a 2016 Ford f150 lariat crew cab on 11/3/2018 and was coming to work on 11/5/2018 and the it started to idle roughly very slightly when at a stop in traffic, this happend about 3 times each time getting worse and then it did stall on the 4th time and it was a noticeable rough idle.

While traveling on interstate at a speed of 80 mph, my 2016 F-150 eco boost with 50,000 miles went into limp mode due to a faulty electronic throttle body causing me to lose the ability to accelerate and worrying for my family's life as I was decelerating on a busy 4 lane freeway trying to find a way to pull over without being smashed.

Complete unexpected loss of power at highway speeds or when accelerating. Has happened repeatedly even after several repairs related to the throttle body by dealer. First happened in the 40,000 mile range and after repairs again at 83,000 miles.

While driving on a busy highway with no warning my F-150 lost power. When this happened the drive power decreased by about 95%, and warnings appeared on the dashboard. These warnings included: service advance trac, hill descent fault, see manual, airbag fault, and the service wrench. The engine idled roughly and the vehicle had to be turned off. We restarted and the same issues occurred so we parked the vehicle.

I was merging onto a highway and I went to accelerate and li ended up with a complete loss of power, no acceleration, and a flashing wrench on my screen telling me that I was having a hill decent issue and service advancetrac error. As I tried to get off the road once I lost power; the car started shaking violently while at a complete stop.

2016 f150 with the 2. 7l ecoboost randomly dies after startup. Sometimes it will die while in motion almost causing an accident. There's no stored codes for the dealer. It's been in the shop 6 times total. The first time they put a crankcase vent sensor and then the 2nd time sparkplugs. It's dies and gone into limp mode multiple times but the dealer can't duplicate the problem so they can't fix it. It started at 9,000 miles and it now has 14,000 miles. I'm pretty sure it's the throttle body but they won't replace it without a code. It has happened randomly from March 2017 until today 8-13-17. I also have a recording saved on my snap-on scan tool of the parameters at the time it went into limp mode.

For the last year my car have been leaking fumes and smelling of carbon monoxide. I have complained to mission valley Ford, big valley Ford and all star Ford. When I start the vehicle there is white smoke and a strong fume. They said it's the ecoboost. Secondly the turbo they say has gone out already at 87k miles and I believe the smell and the turbo is connected.

Driving about 50 mph lost engine speed suddenly to about 10 mph. Have been told by 2 others that this also happened to them. Same truck model. Root cause given was throttle body cable. Accelarator box. Having ours towed to dealer ship today. Under 10,000 miles on vehicle.

On 1/25/16, in the rain, at 6 am, I pulled out from a side street near my residence on to a major road and was increasing speed. I traveled about 150 yards and was up to about 40 mph. My truck suddenly decelerated to about 5 mph very quickly causing my car to skid in the rain. There was no accident since traffic was light at the time, so I pulled into the median and put the truck in park to see what was happening and I could not discover anything wrong. I then put the truck in gear and tried to accelerate again but the car would speed up to about 15 mph and then decelerate very quickly, almost giving it a bucking motion. After a few seconds the truck seemed to want to die, it would move and then seem to want to stop and die, and then repeat the process. I was able to get to the side of the road and park in a parking lot. I had my truck towed to the dealer and the dealer looked at it but said they couldn't find anything and had never heard of that happening to anyone before. I looked on the NHTSA site and found that many people had had this occur in this model. The work order received from the dealer did not indicate that anything was adjusted or replaced. To date it has not reoccurred.

The contact owns a 2016 Ford F-150. While driving at any speed, the vehicle made noises from the engine and transmission areas. The contact stated that the vehicle consumed too much fuel and the air conditioning blew hot air. Also, the oil low pressure warning indicator illuminated and flashed off and on. The contact also stated that the brakes squeaked and the front passenger side tire deflated. The vehicle was taken to the dealer (koons Ford in sterling, va) for diagnostic testing. The dealer found nothing wrong with the vehicle; however, the failures recurred several times. The contact stated that the vehicle was taken to the same dealer several times and, during one of the visits, the engine was replaced without the contact's consent. The manufacturer was made aware of the failures and did not assist. The vehicle was not completely repaired. The failure mileage was approximately 40.

2016 Ford F-150 2. 7l ecoboost model with only 3,928 miles. This is the third time engine has cut off on me while driving/accelerating! was taking a left turn from side road onto main road. While accelerating in the turn, engine started stuttering a few times (rpms would dip) and then it stalled out. Luckily I was able to complete my left hand turn without getting hitting by oncoming traffic and was able to pull over immediately. This time around the engine would not restart. Had to call Ford's roadside assistance to get towed to nearest dealership. The last two instances the dealer could not pull a code or diagnose what was wrong so nothing was done. This time the dealership has a dead truck on arrival so they can't tell me that there is nothing wrong with it (service and diagnostics has yet to be completed at the time of this writing). I have been in touch with Ford regional rep regarding my cases and I am told they cannot do anything until the dealer can diagnose what the root cause is. Obviously something is wrong. There are dozens of other complaints of engine stalling while driving.

Truck was running normal no check engine lights,making rt. Hand turn onto highway truck started to accelerate then the accelerator pedal quite working lots of dash warning lights came on and truck would only idle,used hazards to idle off highway , shut off ignition and restarted truck still would not accelerate,let truck idle in gear to get off highway,let truck sit over night and tried to drive next morning started to accelerate then quite idle only called to have towed to dealer for repair,dealer replaced throttle body.