general problems of the 2023 Ford F-150 - part 1

The epb system has a fault and service now code. This puts a risk on safety of me, passengers and others on the road. This make and model is a single exhaust unit and I believe it has to do with an open recall. July 21, 2023 NHTSA campaign number: 23v509000 unexpected activation of electric parking brake unexpected activation of the electric parking brake while driving increases the risk of a crash. Nhtsa id number: 23v509000 manufacturer Ford motor company components parking brake potential number of units affected: 870701 summary Ford motor company (Ford) is recalling certain 2021-2023 F-150 vehicles equipped with a single exhaust system. Contact with the rear axle housing may damage the wiring harness, causing the electric parking brake to activate unexpectedly.

I was on the highway doing 70mph and went to break and I had no brakes. I was terrified. I kept trying and I got it to break and pressed again and lost them again. Eventually the pressure on the breaks returned. The remaining ride home was just scarey.

Electronic parking brake warning was coming on and parking brake was inoperative during this period of time. Vehicle is at the dealership now and diagnosed with corroded and broken wires in the left rear harness for the parking brake. Ford will not assist with this repair even though it is very similar to the problem involving recall 23s35 which inspects and replaces this same harness due shorting out wires which could cause the parking brake to lock up while driving.

The electronic brake booster system failed while driving the vehicle causing the brakes to lock up and almost caused a collision with a tree putting me and my family in danger. Car was towed to the dealer and confirmed electronic brake booster failure. There were no prior warning lamps, messages or symptoms prior to the failure during the operation of the vehicle. All warning first appeared after the failure.

I’ve been advised by mcgovern Ford in massachusetts that I need abs module and an electronic brake booster and it isn’t covered by any warranty. Yet it’s a safety hazard and the truck is only 2 1/2 years old. Why would those 2 items need to be replaced on a newer truck.

Complete electrical shut down driving on the highway on two separate occasions. While driving engine shuts off, dash board goes black, infotainment center goes black. Required to shift vehicle into park to restart after occurrence. Huge safety risk! when taken to Ford service; unable to find any issues and was told “vehicle is safe to drive”.

After the vehicle sat parked for 12 days, upon initial startup, the vehicle experienced a total failure of the electronic brake booster (ebb). The dashboard displayed multiple critical fault codes including "brake system failure," "service advancetrac," and "check brake system. " the vehicle software triggered a safety interlock, refusing to shift out of park, rendering the vehicle completely disabled. This failure is a direct match to the defect described in NHTSA campaign 25v488 (Ford recall 25s77). Ford’s official filing for that recall admits the ebb module is "susceptible to normal but infrequent voltage disturbances" which causes the ebb motor to enter a "faulted state" or shut down. My 2023 lightning is currently excluded from this recall despite experiencing the exact same "voltage disturbance" failure mode upon waking from a sleep cycle. This is a critical safety defect that resulted in a total loss of power braking assist and vehicle immobilization. Ford is currently refusing to cover the $2,800 repair cost under the recall, despite the identical nature of the failure.

The contact's mother owns a 2023 Ford F-150. The contact stated that the owner received notification of NHTSA campaign number: 25v512000 (power train); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that there was an abnormal squealing sound coming from underneath the vehicle, near the brakes upon depression of the brake pedal. The vehicle was taken to the dealer, who advised the contact to not be concerned about the squealing sound. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the issue. The failure mileage was 18,614.

While slowing down the vehicle on a downward slop, vehicle applied parking break by itself and stopped the vehicle suddenly with parking break sign on the odometer. There was no object or anything in the front of the vehicle and it was being driven on forward direction. So, this abruptly applying of parking break by itself created a confusion and unsafe situation.

I was parking my car and pressed down on the brake. The car continued to roll forward so I pressed down farther. The car kept rolling forward. I took my foot off the brake and then pressed down hard and came to a stop. The brake fluid is clean and at max levels. The brake pads are relatively new. No visible signs of damage or leaking.

When pressing on the break to come to a stop pulling in parking space, my f150 quickly accelerated cause a crash into a building my 2 year old truck has been declared a total loss from insurance.

On [xxx] at [xxx] I dropped my wife and 2 children off at the funland arcade in deep creek, maryland. The parking lot was full from the holiday weekend and I was planning on taking the lightning to a nearby charger while the family gamed so I double parked perpendicular to the arcade entrance, put the hazards on, and let them out. After the 3 of them got out, I placed the lightning in reverse to back up 5-10 feet so that I could exit the parking lot through the same way I came in. Once I had enough space from reversing so I could make the turn to exit I placed the lighting in drive. The moment the lightning switched to drive it accelerated at a very high speed as if I was flooring the gas pedal, which I was not. The lightning was in one-petal mode which I always use unless I’m on a highway. I immediately began pumping the brakes but the truck would not stop, I probably slammed on the brake petal 4-5 times to no avail. I even tried shifting the truck back into park but it would not shift out of drive. I was able to luckily steer the truck into a hillside approximately 150 feet away. The truck ran over numerous small trees and shrubs before crashing to a stop approximately 16 feet up the hill. Shortly after the shock wore off, I slowly reversed the truck down the hill, exited the truck, and informed dozens of onlookers who came out of the arcade to see what the noise in the parking lot was from, that the truck just took off on its own but that I was fine. I called 911 and the police came. Luckily no people or vehicles were between the arcade entrance and the hillside or the outcome would have been significantly worse. This crash was witnessed first hand by wife and 2 children. I have grave safety concerns about this truck now and will not put my family or self back in it until Ford fixes this problem. I am making this complaint in case this information can help prevent future crashes of this vehicle. Information redacted pursuant to the freedom of information act (foia), 5 u. S. C. 552(b)(6).

While driving my 2023 Ford F-150 XLT through a parking lot at low speed, I attempted to stop and shift into reverse to avoid a tight turn between parked vehicles. With my foot firmly on the brake, I shifted into reverse—though the gear shift was abnormally resistant. The system indicated the vehicle was in reverse. Despite keeping my foot on the brake, the truck suddenly and forcefully accelerated on its own, overriding my braking input. It collided with two parked vehicles before I was able to bring it to a stop by turning off the engine. The vehicle continued to accelerate even while I applied firm pressure to the brake pedal, which depressed all the way to the floor and failed to stop the truck. At no point did I press the gas pedal. After impact, the gear shift remained in reverse with a blinking red light. No airbags deployed. This was an extremely dangerous situation that could have seriously injured someone had they been standing nearby. Additionally, for some time leading up to the incident, I noticed increasing difficulty shifting gears even with the brake fully depressed. At times when in park the light for other gear modes would turn on.   indicating the vehicle may be in another mode other than park.   the brake pedal has also felt inconsistent, often requiring unusually deep and forceful pressure to stop, whether on highways, city streets, or in parking lots. This appears to be a critical failure of both the braking and transmission systems. I am extremely concerned for my safety and that of other Ford drivers. I am requesting a formal investigation into this matter.

While braking slowly to park at my home, my 2023 Ford F-150 lightning XLT suddenly accelerated forward without any throttle input. The vehicle struck a wall. My foot was on the brake and I did not touch the accelerator. There were no warning messages prior to the incident. This could have caused serious injury or worse if anyone was in front of the vehicle. I believe this may be a critical safety defect.

My 2023 f150 has been having issues with the key fob connecting to the vehicle and responding to commands (unlock/lock, remote start etc). On the date of this incident the truck was not responding to the remote start key fob function. While standing outside the vehicle from a distance of about 10 feet I attempted the remote start function with no success approximately five times. On the last attempt I heard the audible sound of the parking brake releasing (moving from the “brake on” mode to the “brake off” mode). Once inside the vehicle I confirmed that the parking brake had been released. I was ultimately able to get the truck started and driving in a normal condition. The parking brake has not malfunctioned since. The key fob / truck connection continues to malfunction to various degrees. Sometimes no response, sometimes no remote start, sometimes the truck will be running and display a dashboard message indicating the key fob is not present leaving the truck running but “locked” in park. During this parking brake incident the vehicle was parked and locked with the parking brake set as normal (on or about may 10 , 2025). It was on level ground in a parking lot. No other vehicles were parked near mine. It was morning time, the truck was “cold” after being parked all night. No other unusual condition were noted. Weather conditions were dry and mild (50 degree temperatures). The remote connection issues have been going on about 6-8 months. I have replaced the battery in the remote 2x with no improvement. The vehicle has been inspected by the selling dealer once for the fob with no results (April 17, 2025). I have an appointment for the latest issues on June 2 2025. It is my belief that the random release of the parking brake system poses a risk for myself and other members of the public that may be injured by a sudden “roll away” of this vehicle by parking brake failure. I am in possession of the vehicle and it’s available for inspection. .

The contact owns a 2023 Ford F-150. The contact stated that while driving at 45 mph, was warning message displayed reading "brake fault detected. Service now. ", prompting him to pull to the shoulder of the roadway no warning lights were illuminated. The vehicle was towed to the dealer, who had not yet provided a diagnosis. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA hotline for assistance. The failure mileage was 14,000.

On three separate occasions when I open my door, I get a “brake fault service soon” notification. I’ve done research and forums say this was a recall in the past. I’m aware my truck doesn’t have any current recalls but it has me wondering if it was ever fixed or if the repair was not good enough. I never owned the vehicle when the original recall came out so I’m not too sure what happened.

Emergency brakes automatically deployed. Vehicle not letting me retrieve key from ignition. Vehicle does not indicate it is in park.

The contact owns a 2023 Ford F-150. The contact stated while driving 35 mph and making a right turn and coming to a stop, the check engine and forward collision avoidance warning light deactivated, and the traction control warning light and other system failure warning lights were illuminated. The contact attempted to depress the brake pedal; however, the brakes failed to respond as needed. The contact coasted down the street and drifted and parked the vehicle. The contact attempted to accelerate; however, after depressing the brake pedal, the vehicle failed to stop as needed. The contact drifted and stopped and turned off the vehicle. The vehicle was towed to the dealer who diagnosed that the electronic brake booster had failed and needed to be replaced. The dealer contacted the manufacturer and opened a case. The vehicle was repaired. The manufacturer was informed of the failure and a case was opened. The manufacturer referred the contact to the NHTSA hotline to report the failure. The failure mileage was 22,075.

When the Ford lightning is in reverse and the 1-pedal braking system is applied, the brakes don't engage when switching to drive causing the car to roll back an additional 3-5 feet depending on speed. In the situation that caused the fender bender, the Ford lightning was reversing in a street at approx. 5 mph then the driver released the pedal for the brakes and switched to drive. The car rolled back 5 feet into a parked car during this transition.

Bought an electric truck in may of 2023 that is frequently malfunctioning while on the road. Turn signals and hazard lights becoming unusable. Gauges w/ speed are turning off and on while driving. All safety features become disabled. Video of multiple occurrences are available and have been submitted to Ford. Would someone please help me and atleast reach out to see the videos of what this truck is doing. I have extensive documentation of my attempts to get this vehicle repaired or off the roads through the bev specialist. My emails are ignored and my phone calls are put in endless loops before being hung up on. I have been trying for 6 months to get them to make my truck safe. I’m scared me and my family or possibly other motorist are going to be hurt if this situation is not fixed. I know I shouldn’t keep driving it but I have to get to work. Purchased an extended warranty for thousands of dollars but after taking to 3 dealerships multiple times a piece no repairs to the computer have been made and they literally have documented they are trying a temporary method for “testing” out unproven “wire overlayment” to bypass an issue with a harness bc they dont want to “condemn” an expensive module on the truck. The computers that control this electric vehicle are failing and I’m scared what is going to happen when if completely goes out while I’m driving at 70 on the interstate. If someone would please look at the service transcripts, my emails to Ford, and videos of this vehicle malfunctioning I would be sincerely grateful and appreciate any guidance.

While driving in sport mode multiple times, received "drive mode not available" message. Vehicle reverted to normal mode changing expected regeneration braking force. No other issues with the vehicle noted or stored in can. Seems to be a software glitch but arrives randomly and unexpectedly changes expected regenerative braking force requiring more driver input.

While driving up to 40 mph, the emergency brake will randomly come on causing me to skid and stop suddenly. I manually have to turn back off the emergency brake to drive again. This incident has occurred in traffic multiple times. The truck has been at the dealership service center four times and they cannot replicate, diagnose, or repair the issue. The dealership states they have looked at the electrical components and replaced the battery, which did not solve the issue. There are no warnings prior to the emergency brake coming on. A collision is not about to happen that causes it to come on.

The contact owns a 2023 Ford F-150. The contact stated while driving at approximately 30 mph, as he depressed the brake pedal to slow down for a traffic sign the vehicle was not slowing. The contact stated that he had depressed the brake pedal to the floorboards and the vehicle was not stopping. The contact stated that his vehicle ran the traffic sign and he crashed into a vehicle that was in the intersection on the driver's side rear wheel well. The contact stated no warning light was illuminated. The contact stated that the road surface was wet due to rain. The contact stated that his air bags were deployed. The contact stated that his front bumper was crushed and the hood was crumpled back. The contact stated that the state police were on the scene and issued a report. The contact stated that a neighbor drove him to a local emergency room. The contact stated that he had pain in his right knee, pain in his left wrist and minor cuts on his left wrist. The contact's vehicle was towed away from the scene. The contact was not sure what happened to the other vehicle. The manufacturer was not informed of the failure. The contact had researched online and related the failure to NHTSA campaign number: 21v533000 (service brakes, hydraulic). The failure mileage was approximately 12,000.

Stoped truck to get gas ! put in park ! when I got out of truck it went in reverse almost running me over !! ripped my driver door all the way around to the front wheel before I could get it to stop !! it is equipped with a sensor to automatically put it in park when door opens !! but it did not happen !!!.

The contact owns a 2023 Ford F-150. While coming to a stop light the contact noticed a failure with the automatic lock brakes. The contact stated that the brake pedals depressed, which caused the contact to lose control of the vehicle which caused the contact to rear-end another vehicle with no warning lights illuminated. No injuries were sustained, and medical attention was needed. A police report was filled with the montgomery sheriff's department and a report number was provided to the contact. The vehicle was not towed and was able to restart. The dealer was contacted, and the vehicle was not diagnosed or repaired the manufacturer was made aware of the failure, and a case was opened. The failure mileage was approximately 46,000.

Numerous times while emergency braking my foot pushed on accelerator and brake at the same time called Ford and they said take to dealer called dealer and discussed the problem I said it is a design problem and they said if designed that way nothing they can do accelerator is 5/8" wider than my cars.

At 65mph driving in sport mode which has increased regeneration during deceleration which provides substantial braking, I was approaching stopped traffic. I let off the throttle pedal anticipating the braking effect and regeneration but the truck instaneously switched driving modes to normal without my input. It took me a second to realize I was not slowing and had to manually activate the brake pedal in order to stop in time. I tried to reselect sport mode after stopping and it was greyed out with a message saying some features are disabled while driving. Normally you can switch drove modes while driving. After restart truck returned to normal operation. The danger was the unantisipated change to braking effect during a critical time before a high speed stop.

Coming off the freeway, heard a loud noise in the rear of my truck. Then it sounded like rocks were getting pulverized. Put the vehicle in park and since we (me, wife, and two children) were on a decline the brakes did not work and our truck drifted into oncoming traffic. Luckily cars were able to avoid us in time where we pulled off onto the shoulder and engage the parking brake.

The contact owns a 2023 Ford F-150. The contact stated that while his wife was driving at an undisclosed speed, the brake pedal became soft while attempting to stop the vehicle. The contact examined the vehicle and discovered that the brake fluid reservoir was empty, and the brake line fitting was not properly secured, causing brake fluid to leak from the brake lines. The brake line fitting was secured by the contact and the vehicle was repaired. The manufacturer was notified of the failure. The local dealer was not contacted. The failure mileage was 3,000.

The contact owns a 2023 Ford F-150. The contact stated that while driving at various speeds or while in stop-and-go traffic, while depressing the accelerator pedal, there was an abnormally loud plastic-on-plastic sound. The vehicle was taken to the local dealer, where it was diagnosed with a brake booster failure. The vehicle was repaired, but the failure recurred two months later. The contact stated that there was popping and clicking sound in the brake pedal. The contact stated that it felt as if the brake pedal was cracking. The failure was more prevalent after being parked or while driving for long distances. There were no warning lights illuminated. The vehicle was taken to the local dealer, who determined that the vehicle was working as designed. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA hotline for assistance. The failure mileage was approximately 10,000.

The parking brake engages randomly when the 2023 f150 lightning lariat er comes to a stop while driving, thus increasing the risk of a crash. Dealership is "unable" to replicate the issue which currently occurs several times per day. Https://youtu. Be/sj4ipiz-qja.

Driver instrument cluster shuts off , go's black and resets while driving vehicle. Antilock and airbag system show failure message on Ford app. Instrument cluster then reappears condition reoccurs approximately every 5 minutes.

Transmission jerking, harsh shifting, clunking, lunging, and hesitating. I have taken this truck to hagerstown Ford for repair. They advised they were able to duplicate the problem and found the transmission was 1. 5 quarts low on fluid. I have driven the truck a few hundred miles since and the issues are still there. I also understand Ford is having issues with the 10r80 transmission and there have been recalls but mine is not applicable. I have also had two occasions with the park brake not fully releasing and getting a service park fault now appearing on the dash. They said there were no codes, and everything is, ok?.

My parking brakes just comes on as im driving. This has become a dangerous situation as its caused my car to suddenly stop in different driving situations.