Table 1 shows one common service brakes related problems of the 2026 Ford F-150.
| Problem Category | Number of Problems |
|---|---|
| Service Brakes problems |
Received vehicle back from dealer saying prior brake problems had been repaired and confirmed with Ford engineers. Drove approximately 3 miles before brakes failed again and I was not able to stop at the intersection. Avoided an accident, but had vehicle towed again to be repaired. This is the third complete brake failure in less than 300 miles on the vehicle.
I purchased a brand-new 2026 Ford F-150 raptor from ken grody Ford on August 25, 2026. On August 26, 2026—one day after the purchase—I was traveling in traffic at approximately 45 mph when the truck suddenly lost power-assisted braking and most of its braking effectiveness. The brake pedal required extraordinary pressure, and even with that pressure the truck was slowing only marginally. I activated my hazard lights and had to cross multiple lanes of traffic while attempting to bring the vehicle to a safe stop. This created an immediate and serious risk of a collision with surrounding motorists. Multiple warning lights and messages appeared, including a red “check brake system” warning. After I had safely pulled over, I recorded a video showing the warnings displayed by the vehicle. The truck had only 255 miles on it at the time. No collision or injury occurred because I maintained control of the truck, activated the hazard lights, applied extraordinary pressure to the brake pedal and took immediate evasive action to reach a safe location. I immediately reported the incident to ken grody Ford. Because this serious braking failure occurred one day after I purchased a brand-new vehicle, the dealership subsequently agreed to unwind the transaction. As of August 28, 2026, I have not received a definitive engineering explanation identifying the cause of the failure. I am reporting this incident because the sudden loss of power-assisted braking and severe reduction in braking effectiveness in a virtually new 2026 Ford F-150 raptor created a substantial risk of injury or death. I request that NHTSA document and investigate this incident and determine whether similar braking-system failures have occurred in other Ford vehicles.
1. Vehicle sat in a storage unit for 2 weeks. Battery registered adequate voltage when picking up vehicle 2. Started vehicle, engaged 4 auto due to rain 3. Drove 16 miles in light to moderate rain at speeds of 30-60mph 4. Made multiple stops at stoplight in town. When waiting at a red light, my foot was on the brake pedal for about 20 seconds, the pedal then jolted up a small amount. The dash immediately displayed several warning lights and messages: antilock brake fault, antilock brake system fault, powertrain malfunction/reduced power fault, electronic parking brake fault, hill start assist fault, precollision assist fault, service advance trac warning, advanced front lighting features fault. 5. The light turned green and I proceed to the next light to turn off the main road and park in a neighborhood to call a tow truck. 6. In the process of slowing down for the turn, I applied pressure to the brake pedal, and it went to the floor with no resistance. Brakes were 95% gone. 7. Luckily there were no cars or pedestrians in front of me and I was moving under 30 mph. This could have been catastrophic! I was able to use the transmission to downshift to slow the truck down. I was also able to apply extreme pressure to the brake pedal to barely slow the truck. When pressing hard on the brake pedal, I could here one or both of the rear tires sporadically screech, as if they locked up a small amount. 8. Finally was able to pull into a neighborhood and call a tow truck to bring truck to dealership. 9. When turning vehicle on to load onto tow truck. The vehicle started as no normal, with no warning lights and normal brake operation. Awaiting further diagnosis from dealer. 10. I have lost all trust in this vehicle if the brake sporadically give out without warning. Luckily this did not happen while going 80mph on the highway and needing to make an emergency stop. Or while offroading on a shelf road with a 100 foot cliff on the side. Easily could be dead due to this failure.