Table 1 shows one common engine and engine cooling related problems of the 2022 Ford F-450.
| Problem Category | Number of Problems |
|---|---|
| Engine And Engine Cooling problems |
The contact owns a 2022 Ford F-450sd. The contact stated while driving 50-65 mph, the vehicle lost drive power and the instrument panel lights started flickering. The check engine warning light was illuminated. The contact was able to pull over to the side of the road. The vehicle was able to restart, and the contact resumed driving. The contact stated that the failure recurred while driving on several occasions. The vehicle was taken to the dealer, where it was diagnosed and determined that both batteries had failed and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 75,000. The VIN was not available.
I was towing my 5th wheel trailer on a highway and up an incline. Almost at the top of the hill a notification appeared on the dash screen stating, "low power mode". As I was on top of a hill, towing a trailer, on a highway, and with no available offramps, I coasted down the hill trying to find a place to pull off of the highway. At the bottom of the hill I heard a loud noise from the engine, noticed smoke in my rearview mirror, and lost all power to the vehicle including power steering. I managed to pull off to the side of the busy highway. I exited the vehicle and removed my kids from the car, moving them up a hill on the side of the highway as it was the safest place I could find. It was at that point I noticed flames coming from the right font front wheel well. I quickly opened my trailer, grabbed my fire extinguisher, and doused the flames. Had I not acted quickly the entire truck, trailer, and hillside would have caught fire. The vehicle is still at the dealership waiting on Ford motor company to approve the repairs. The vehicle has approximately 26,000 miles on it and is unmodified.
On 6/7/24, while driving around the baltimore beltway towing a 44' RV in rush-hour traffic a battery warning light appeared. Within 1 min, the vehicle dashboard information went out and the engine stalled. I immediately put the vehicle in neutral and was able to coast to the shoulder without advantage of turn signals on either the RV or truck as a result. Once there I popped the hood and was able to get out to open it, however, there was a fire and my fingers were singed. After opening the hood, I noticed a full engine fire. I yelled for my wife to get out ASAP. I was able to extinguish the fire (thanks to the RV extinguisher), however, a secondary fire started, and a samaritan help extinguish that fire. A fire department truck appeared, and they cut the batter cable since it seemed to have started the fire. The vehicle was towed back to the dealership where it was purchased. The insurance agent stated a mechanic had informed him; they believe it was the battery that was the cause. All vehicle maintenance was conducted by the dealership due to warranty and an extended vehicle maintenance plan purchased at the time of sale. Ford has failed to acknowledge any problems with the vehicle and refused to honor the warranty.
The contact owns a 2022 Ford F-450 sd. The contact stated that while starting the vehicle, he started to hear a loud knocking noise coming from the engine. No warning lights were illuminated. The vehicle was towed to the dealer where it was diagnosed and determined that the engine needed to be replaced. The manufacturer was notified of the failure and advised the contact to reach out to nhsta hotline for assistance. The failure mileage was 168,000.