Two problems related to instrument panel have been reported for the 2004 Ford Freestar. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2004 Ford Freestar based on all problems reported for the 2004 Freestar.
The contact owns a 2004 Ford Freestar. While driving approximately 35 mph on normal road conditions, the idle speed increased and the vehicle accelerated unexpectedly. Suddenly, the vehicle stalled. The engine restarted and resumed normal operation. In addition, the vehicle failed to operate intermittently when shifted into reverse. The engine warning light illuminated on the instrument panel and remained lit until the engine was turned off. The vehicle was taken to an authorized dealer for inspection and they stated that water was leaking from the front windshield, which damaged the computerized system. The vehicle was repaired. On a separate occasion, the vehicle was taken to an authorized dealer and independent mechanic for identical failures. The vehicle is in the process of being repaired. The failure and current mileages were 58,000.
The contact owns a 2004 Ford Freestar. While driving approximately 35-40 mph, the vehicle began to hesitate and the instrumental panel lighting flashed. The vehicle shut off a few minutes later and was towed to the dealer. The dealer stated that water penetrated through the windshield wiper motor area and caused the main computerized system to fail. The instrument panel had to be replaced, the gas line had to be blown out, and the spark plugs were replaced. The insurance company investigation concluded that the failure was due to a product defect. The manufacturer acknowledged receiving the contact's written complaint; however, they would not assist with the $1,200 repair cost that the contact had to pay. The failure mileage was 58,502.