Table 1 shows one common electrical system related problems of the 2022 Ford Ranger.
| Problem Category | Number of Problems |
|---|---|
| Electrical System problems |
What component or system failed or malfunctioned, and is it available for inspection upon request? inspection available if needed. The ignition coils and spark plugs failed due to Ford’s negligence to provide an engine cover. Water has gotten in to the engine and caused these systems to fail how was your safety or the safety of others put at risk? the engine violently shakes and causes you to lose speed. I was going 20 under the limit on the highway due to this and could have caused an accident. The vehicle felt as if it was shutting off and I got off at the next available exit. It placed my family at risk and others as it could have caused a bad accident if someone would have rear ended me due to the slow speed. Has the problem been reproduced or confirmed by a dealer or independent service center? yes, this is a known issue and Ford refuses to repair the vehicle and advises it is out of pocket. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? the vehicle has been inspected by a repair facility. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? the check engine light was flashing and then stayed solid. This first appeared on 1/27/26.
Wiper arm stops working or stays in up position. Intermittent issue.
The acm (audio control module) failed, causing a network failure in the can system. This caused a condition of no speedometer reading, no automatic braking, no adaptive cruise control, no fuel gauge reading, no blind spot monitoring, no forward collision, no rear cross traffic warning. Additionally, while the turn signals worked, there was no inside audio or visual confirmation that it was functioning. Also no high beam headlight indicator and no automatic high-low beams. Cost of repair was $739. 00 and the dealer had to order the part.
Truck cut off at an intersection without warning and would not turn back over. After multiple attempts and aaa service members checking batter car would not start. Has power but will not turn over dealership is saying there is a module issue but is not sure.
The contact owns a 2022 Ford Ranger. The contact stated while the vehicle was parked, the vehicle failed to start with the key in the ignition. The contact stated that the vehicle started after the battery was recharged. The contact was able to start the vehicle using the key instead of the key fob. The vehicle was taken to a local dealer to be diagnosed; however, no cause for the failure was found. The manufacturer was notified of the failure and referred the contact to the NHTSA hotline for assistance. The failure mileage was approximately 14,000.
Had someone driving behind me flag me over. I had no tail lights, brake lights, turn signals front or rear or hazzard lights in the front or back. There is only 15,000kms on this truck. Head light low beam and high beam work. Trying to get in contact with Ford canada and a Ford dealership. Was scanned at a shop and showed multiple body control module faults and looks like a module. But not touching the vehicle as it has the max warranty they sell this vehicle is in nova scotia, but came from the michigan plant. It will not accept my canadian address.
Modem cannot connect to update features nor use remote features.
The contact owns a 2022 Ford Ranger. The contact stated that while driving on several occasions, the infotainment system screen turned black intermittently. Additionally, the contact stated that upon starting the vehicle and accelerating, the vehicle failed to accelerate as intended. The vehicle was taken to an unknown dealer on several occasions, but the failure could not be replicated. The vehicle was taken to autozone, where it was diagnosed that an unknown O2 sensor located behind the glove box, and the sensors connected to the catalytic converter had failed. The vehicle was not repaired. The manufacturer was notified of the failure and a case was filed. The failure mileage was approximately 300.