Five problems related to suspension have been reported for the 1996 Ford Taurus. The most recently reported issues are listed below.
The frame of my 1996 Ford Taurus has rusted out where the frame mounts to the body on the right side.
The incidents have all been the same: the car is usually going under 35mph. The car starts to shake, the service engine light on the dashboard lights up, the car acts as if there is not enough gas getting to the engine and the engine either cuts off or begins to chugg and shake any time the car slows or stops. I'm sure you can understand how frightening this can be since I never know when this situation is going to occur and I'm petrified that it will happen during rush hour on a major road causing accidents and major damage. The first time it happened, I was within feet of a service station and brought it to them. The code on the engine light sensor was, "egr". They did a 60,000 mile service, checked the emission system, and found nothing. After 41 miles, the engine light was on again. I took the car to the same service station. They replaced the dpfe sensor. I've since taken it back to them 3 or 4 times, whenever the car starts to shake and the service engine light turns on. They have done everything that they can think of to fix the problem and are at a loss as to what to do. They even had a class with 50 technicians given by the representative of the diagnostic machine and used my car as the example. They took apart the entire emission system and "roto-rooted" it. I drove less than 10 miles and the car started shaking again. So far, I've spent close to $500. Because the garage where I originally took it didn't fix the problem, they haven't been charging me for return visits. I contacted Ford's consumer help line on may 2, 2000. Damien said that because I'd had so much trouble, he thought that I would get some financial help from Ford and he'd let me know in two days. When I didn't hear from him, I called Ford again and spoke with carol. She said that I would get no help and that my first step was to take the car to a Ford dealer & thay would help me. They don't want to help me. What can I do?.
While pulling out of the driveway and turning to the right, there is a loud noise coming from the vehicle and something is rubbing under the vehicle. The consumer can't determine where the noise is coming from.
Car make loud squealing noise when makeing sharp turns. This has been going on for a long time. When car was brought in under warranty they couldn't find anything wrong.
Vehicle recall notice sent, vehicle has experienced rattle and creaking since new.