Fuel Hoses Lines/piping And Fittings problems of the 2002 Ford Taurus

The contact owns a 2002 Ford Taurus. On 10-05-05 he took vehicle dealer for a routine fuel filter change. On Saturday 10-08-05 the car would not start. He saw a puddle of gas by the right rear wheel. He got down and looked under the car, and saw the hose that goes from the tank to the filter loosened. He pushed it back on. But on 10-10-05 he went to a gas station to have a mechanic look at it. The line came off the front of the filter was on , but the line coming from the gas tank on the rear was about to come off again. The mechanic pushed it back on securely. He drove the car home and called the dealership. That same day the line came off again. (from the gas tank to the filter). He put it back on and drove out to the dealer. When the mechanic came out the car would not start. The gas was pouring out again because the line had come off again. The mechanic went and got some new clips and put the new clips on. He has not had the problems since the clips were put on. He is not sure if this is a defective part or if maybe the mechanic that originally replaced the fuel filter did not properly follow Ford's procedures.

The smell of gas was light at first but kept getting stronger. I finally took the car to a certified repair station. The serviceman said that the gas line was mounted so close to the exaust system that the gas line melted and started leaking. He said that if I had waited any longer, the gasoline leak may have caught on fire.

2002 Ford, Taurus se 4 door. Every time vehicle was started consumer smelled gas. Vehicle was taken to a garage where mechanic discovered that gas line above catalytic converter had been rubbed until it began to leak. Gas line was made of something other than metal. The consumer said that his mechanic had same type vehicle and was also smelling gas. The mechanic refused to use Ford parts to fix problem. The mechanic rerouted the gas line around catalytic converter using metal line for the gas line. Consumer still has gas line that was replaced, consumer will send line to odi. Consumer wanted a refund from Ford due to the poor location the fuel line was in.