Table 1 shows one common engine and engine cooling related problems of the 2024 GMC Canyon.
| Problem Category | Number of Problems |
|---|---|
| Engine And Engine Cooling problems |
Coolant leak caused by known manufacture defect in upper hose assembly causes coolant to drain and engine to overheat. Cel only comes on when coolant is almost gone. GMC refuses to cover the known issue after 36k miles.
Upper radiator hose connection to radiator is faulty causing leak of coolant. Yes it is available for inspection upon request. Truck began to run cooling fan at full speed in the middle of winter with no warnings of high heat or low coolant. After two weeks, check engine light finally cut on to indicate low coolant flow. Coolant reservoir was subsequently checked and found to be completely empty. It is apparent this reservoir had been extremely low / empty for at least two weeks with no warnings. Without proper warning and leaking coolant, truck could have overheated. Should this had happened in dead of summer, truck could have very well overheated with no warning. The problem was investigated and confirmed by dealer as leaking coolant at the connection of the upper radiator hose to the radiator. Was quoted $983 to replace the hose. No warning lights appeared until issue had been ongoing for over two weeks. A quick search of "GMC Canyon upper radiator hose" will reveal many identical occurrences of this issue. This is a safety hazard / design flaw that gm is not acknowledging and is putting the burden on the vehicle owners for their own issue.
Coolant leaking at 22k miles, smell of coolant, check engine light on and off 2x's. Coolant evidence on driveway and in engine cabin. Known condition for gm model. No parts available for replacement. No recall for issue.
There are widespread reports of the o ring seals on the radiator and heater hoses failing and causing coolant leaks. These leaks are significant enough to render the vehicle inoperable and with no cabin heating or cooling. This could lead to life-threatening situations in adverse weather conditions. It could also create dangerous roadside failure situation in heavy traffic, particularly on interstate highways. Dealers are aware of the issue and are currently repairing vehicles under warranty. However some dealers are telling owners that the cooling system is not part of the engine and drivetrain, and therefor is not covered under the original factory warranty if the vehicle has exceeded the initial bumper to bumper warranty limits. Dealers are also telling owners that parts are on backorder due to high demand, and that repair wait times could take weeks. The vehicle is unsafe to operate with a known coolant leak. Video of leak (another owner) here. [xxx] information redacted pursuant to the freedom of information act (foia), 5 u. S. C. 552(b)(6).
Upper radiator hose attachment is leaking due to faulty rubber gasket. This comes up across GMC Canyon groups on facebook 10 times a day. It is happening to all of them mainly pre 2025 on 3rd gens. Part is on back order at all GMC dealers due to so much volume of issue. Happening as early as 10k-20k miles on brand new trucks causing over heating issues due to coolant leaking out. Hopefully a recall for the part is done before engines start blowing.
Truck began idling very rough. Went straight to the dealership. They shut the truck off and it would not restart. No cel or messages on the dash. Tear down reveled a failed exhaust valve in cylinder #4. Truck has 10,000 miles. A replacement engine has been ordered under warranty. Luckily, we happened to only be a few miles from a dealership when the failure happened. There was no warning, no prior symptoms what so ever.
Upper radiator hose leaks where it connects to radiator. 40k miles and my truck has no coolant.
I've noticed an issue since I picked up my vehicle from its last service where the rpms stay around 1,000 when I let off the gas and should be coasting. The vehicle will continue to accelerate at 11 to 13 mph, and I really have to mash the brake pedal to stop. There is an update notice that popped up starting yesterday, but it will not install. Looks like the update is for the issue I am having. The update was supposed to be installed already per the service bulletin. Update number is n242452130.
2024 GMC Canyon elevation trim 4x4 with 31,000 miles on it always had maintenance every 5k interval. I noticed an upper radiator hose leak significant enough to require a decent amount of coolant and decided to take it in to GMC to get it repaired. Mind you this repair is almost $1,000 to get repaired with the hose itself only costing $148. It's disappointing to have such a new truck and have these kinds of problems and upon research there seems to be several others with the same problem relating to an o ring in the upper radiator hose. Considering the truck is routinely serviced more frequently than required I see this as an issue for someone to run out of coolant and possibly be stranded on the side of the road if gone unnoticed and needs to be properly addressed ASAP.
The contact owns a 2024 GMC Canyon. The contact stated that while driving at various speeds, the steering wheel was rattling abnormally. The check engine warning light was briefly illuminated. The vehicle was taken to a local dealer, where the vehicle was test-driven; however, the failure was not identified. The failure reoccurred, and the vehicle was taken back to the same local dealer, where it was diagnosed as needing a rear intermediate steering shaft, and a retest was performed. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken back to the same local dealer, where the vehicle remained under investigation. The manufacturer was made aware of the failure. The failure mileage was approximately 4,491.
Propulsion of vehicle. Truck lost power as I was trying to pull into traffic at an intersection. Yes, it was confirmed by the dealer; truck was returned after 3 incidents. Gm has been inspected the truck. Yes: check engine light immediately came on, and a comment then stated onscreen: "caution. Your vehicle has lost power and is operating at a reduced capacity". First occasion, truck was approx 6 months old. Second was 1 month later. Third and dangerous incident occurred June 11th 2025. Dealer keeps saying the truck is ok. Failure to propel keeps happening. Service supervisor tells me truck needs a new module, but gm won't approve it. Truck is still at the dealer, and issue has been escalated twice. Truck still at dealer.
Vehicle whole system was non existent. No interior lighting, no door chime when opened, no response. Mechanic took a look and found alternator not good. It’s not charging the battery and advised me to tow it to warranty repair shop. Advised me if I were driving and vehicle died I would not have power or control of vehicle and cause serious injury or death. Lucky I was parked at home and attempted to start vehicle to leave home. No repairs done yet, vehicle is still at home waiting for an appointment.
On 2 occasions the battery was drained and a tow truck had to jump the battery. On one occasion after the battery was jump started it took several hours before the brakes were able to be used and the car driven safely. Had to drive very slowly (under 50 mph) per note that appeared on dashboard. After nearly an hour of waiting engine light stayed on and dealership ran diagnostic and found nothing wrong with the battery nor anything else. Have to start and run engine everyday to keep battery from dying. If not started in 24 to 36 hours, battery will die.
Where to begin. . . As I bought my first truck, literally within 10 days after buying the GMC Canyon 2024, the car is shaking uncontrollably on the highway. . . 35 mph max speed, extremely dangerous situation, 8 am on a busy watterson expressway in louisville, ky. I was so scared I was going to crash and potentially get hurt or worse. They told me "they had never seen this happen to a Canyon before" which is obviously a lie. The car was serviced for 21 calendar days, and now my lights are spotty and I can't drive my car at night. I got this truck [xxx]. There was no communication on when it was to be ready. There are issues with a lot of minor things as well like the navigation systems. I have logged every call with the dealership, courtesy Buick GMC in louisville as well as summarized every point of contact, and with very spotty responses and the manager, frank, wont respond to my emails and was extremely uncooperative as I asked to trade it in as I was genuinely concerned about my safety and he told me absolutely not. Information redacted pursuant to the freedom of information act (foia), 5 u. S. C. 552(b)(6).