Table 1 shows one common other fuel system related problems of the 2026 GMC Sierra 1500.
| Problem Category | Number of Problems |
|---|---|
| Other Fuel System problems |
I was driving on 96 w. In slow traffic on the freeway when the vehicle put itself in neutral and shut off.
I bought a new GMC Sierra 1500 denali with the 6. 2l v8 engine in December of 2025. 7 months later, I was driving home from work. When the car started, it sounded a little louder, but not out of the ordinary. I started driving and got a strange rattle when I was getting on the highway at around 65mph. I pulled off at the next exit and checked my fluids, checked under the car to see if anything was caught that was causing the rattle. All pressures and fluids were normal. I had onstar run a system diagnostic. The diagnostic read normal. I got back on the highway and drove about 20 miles at 75mph. The rattling continued. 20 miles later, the check engine light came on. I had onstar run a diagnostic and came back stating “engine and transmission system problem” with two error codes. One code said “an issue has been detected in the variable valve timing system adjust the timing of fuel delivery for more efficient engine operation”. The other code said “an issue has been detected in the ignition system which oversees the timing and spark necessary to ignite fuel in your engine” both error codes said to fix within one day. The GMC dealership was on the way home so I was going to stop there and see what they could do. I never made it to the dealer. About 2 minutes after the diagnostic, while doing 75mph on the highway, I hit the accelerator and the car did not speed up. The engine then shut off while I was in the left lane doing 75 mph. The electronics stayed on and the dash stated “press start to start engine. ” I pulled over to the side of the highway and put the car in park and attempted to restart the engine. The engine never turned over again. I could not get the engine to start. I could not shift the car to neutral to have it rolled up on to the tow truck. My truck was towed to the GMC dealership and they are now replacing the engine under warranty. Will upload any maintenance paperwork once engine is replaced.
Bought the vehicle brand new at the end of April. 2 weeks later and at 557 miles, the engine had a lifter failure and needed to be replaced. One day after picking it up after the engine replacement, a fuel injector went bad and needed to be replaced. About 2 days ago, the check engine light lit up, and the GMC app said it was a code for the transmission system (popped on after attempting to remote start the vehicle, although the light did shut off on its own the next day after a software update on the vehicle).
I bought the vehicle brand new in April 2026. On may 3rd, approximately 2 weeks after I bought it, I experienced a lifter failure that caused metal to get into the oil pan/engine and the engine needed to be replaced. About a month later after repairs were complete, I picked up my vehicle on a Friday night, and the very next morning, had issues again. Took it back to the dealer and a fuel injector went bad and needed to be replaced. I recently attempted to use the remote start feature and as soon as it fired up, the engine cut out. I went to start it again and the check engine light came on. My GMC app said the code was transmission related, although it cleared on its on the next morning after a software update.
"vehicle is experiencing symptoms consistent with the 6. 2l l87 engine bearing failure investigation (NHTSA probe January 2026). Despite two repair attempts, the dealer claims 'operating as designed. ' I have experienced persistent engine stumble,hesitation, erratic tachometer needle flutter and significant vibrations felt through the floorboard and seats during operation. These defects substantially impair the use ,value and safety of my vehicle. This is a serious safety concern as it creates a risk of catastrophic engine seizure at highway speeds. Manufacturer has been sent a formal 'last chance' letter under NJ lemon law. " reference # 1771884.
2026 Sierra 1500 at4 with 3. 0l duramax diesel. Three major issues. 1. 2960 miles, thrust bearing failure caused low oil pressure and internal damage. Vehicle needs complete engine replacement. The truck is still at the dealer with no eta on engine arrival and replacement. 2. Vehicle has severe electrical issues. Battery replaced on second day of ownership due to over charge and smoking. The truck would randomly lose the ability to produce sound through infotainment system on start. This includes warning sounds and audible turn signal sound. Dealer said it’s caused by faulty amp which was replaced. 3. The truck shut off (full system shutdown) and the transmission failed over to neutral while driving on the highway and failed to restart. Barely restarted on second attempt. Dealer has no idea why it is doing it. However the vehicle was throwing multiple code related to transmission module failure, brake module failure, transmission module failure, etc.
2026 GMC sierra elevation x31 with 3. 0 duramax diesel engine, 132-miles, thrust bearing 1. 53-mm out of tolerance requiring engine and turbo replacement. Engine build date 25219 (07 Aug 2025), vehicle assembly date August 2025, purchased 10 oct 2025, entered service for engine and turbo failure on 11 Nov 2025, returned 10 Jan 2026.