Other Fuel System Pump problems of the 2004 Honda Odyssey

Corrosion within the fuel pump wiring connector and the fuel pump retaining nut was cracked / broken. Customer complaint was stalling while driving, no start condition. Troubleshooting procedure indicated the fuel pump wiring connector was faulty the inspection revealed that the connector was corroded apparently from moisture. This issue is certainly a safety concern considering the faulty connection can cause loss of engine power -> loss of power steering, and the faulty fuel pump nut can cause gasoline fumes to escape containment which may lead to an explosion / fire. If the connector was jiggled the fuel pump would intermittently operate and or fail. The local Honda dealer refused to recognize the safety recall campaign # 04v42000 or the Honda service bulletin #04-049, and refused to mitigate the problem without offering the option to repair the issue outside of the recall which would cost the customer $454. 32 for the fuel pump repair kit in addition to service fees of at least $374. 00. The vehicle was initially towed-in and presented for service on June of 2018. The Honda dealer is providing wiring harness, retaining nut and gasket at a cost to the customer.

While driving my 2004 Honda Odyssey would completley stahl without any warning, just shut off. . I got the fuel relay replaced and it still stahled numerous times but started back up soon after. . Almost causing numerous accidents just stopping while driving. . Now my van has stahled and this time it will not restart. I have looked up recalls and found one that made sense for a 2004 Honda Odyssey for a fuel pump wire thst has corrosion causing the car to stahl. My vans VIN doesnt fall under this recall. . . . ???.

I own Honda odessy since 09/ 2017. I replaced timing belt with one year warranty, because the previous owner did not do it. 12/09/16 I took my Honda odessy 2004 to manhattan Honda dealership for recall. I asked to Honda representative to check and tell me what is necessary to replace or repair. I knew that transmission recall for Honda odessy 2004 was open and told them to check and repair it if it is necessary, but they refused to do it they told me that my Honda has many issues and repair all necessary things will cost me $10000. The fuel pump, timing belt, which I already replaced, and transmission clutch was included in the repair list. Last month I had a very bad experience when driving this car. It was loosing power and stopping when I was driving. It was dangerous for traffic. It occur on very dangerous spats, like exits from hgway, brooklyn bridge etc. , I could start up car in 5 minutes and it was drawing with no problems then. It was a few times like this and the last time I drove home and couldn't start up the car no more. I towed car to repair shop and mechanic told me that my fuel pump needs to be replaced. I came home and started research and found the recall for Honda odessy fuel pump, for Honda odessy that was built on and after 06/21/04 is on recall for fuel pump repair or replace. My Honda odessy was built 06/2004 I replaced the fuel pump and car is running very good now and I do not have this problem again. Because I had the fuel pump problem after my car was on recall, and because they knew that fuel pump replace was included in recall, and they knew that my car has this problem and did not fixed it I am hereby asking the Honda dealership to reimburse money that I spent on fuel pump repair $653. 03. I also asking Honda dealership to check again a transmission and repair it, if it is necessary.

The contact owns a 2004 Honda Odyssey. The contact stated that while driving 30 mph, the vehicle stalled. The vehicle was towed to repair shop where it was inspected and determined that the fuel pump failed due to corrosion and rust. The failure was related to NHTSA campaign id number: 04v420000 (fuel system, gasoline:delivery:fuel pump). The manufacturer was made aware of the issue, however the VIN was not included in the recall. The vehicle was repaired by replacing the fuel pump. The approximate current and failure mileage was 100,000.

The consumer received a recall notice(04v420000) for the fuel pump no parts were available.

Daily my 2004 Odyssey will stall. The engine will start, run for one second, then shut off. This will occur for one minute to one hour. It first occured when the van had three hundred miles on its odometer. It has been into the dealership four times, but they tell me it cannot be fixed unless it acts up at the dealership. They also told me that I am pressing on the footfeet and flooding the van. Lastly, they told me to hold the key two seconds after the van starts-even though this will wear out the starter. No deaths or injuries have occured due to this, just a ruined vacation and many times of being stranded with a brand new vehicle that will not start. It has never been examined by anyone at a dealership-the service adviser would always send me away without having a technician look at it.