Table 1 shows one common other fuel system related problems of the 2022 Hyundai Elantra.
| Problem Category | Number of Problems |
|---|---|
| Other Fuel System problems |
Vehicle: 2022 Hyundai n line mileage at initial incident: ~17,000 miles components involved: engine and engine cooling; exhaust system / emissions; air bags (srs) I am submitting this complaint to document unresolved emissions system and supplemental restraint system (srs) safety concerns involving my 2022 Hyundai n line, as well as the manufacturer’s refusal to ensure proper diagnosis and corrective action following a documented dealer service error and subsequent warranty repair. At approximately 17,000 miles, a Hyundai-authorized dealership failed to reinstall an engine oil seal during a routine oil change. This error caused rapid engine oil loss at highway speed, activation of the oil warning system, and oil discharge onto the roadway. The incident is documented in Hyundai service records and is not disputed. Sudden oil-loss events of this nature are known to cause latent or progressive damage to internal engine components and federally regulated emissions systems, even when immediate engine failure does not occur. Despite proper maintenance after this incident, the vehicle subsequently set dtc p0420 (catalyst system efficiency below threshold – bank 1) at a mileage far below expected durability. Hyundai replaced the catalytic converter under warranty. I requested diagnostic data, inspection findings, and documentation supporting the repair, but the dealership refused to provide anything beyond a basic repair invoice. Immediately following this Hyundai-authorized warranty repair, the vehicle developed a new drivability defect, specifically hesitation during acceleration, which was not present prior to the catalytic converter replacement. This indicates a post-repair nonconformity and raises concern that emissions-related components may not have been fully repaired or that additional systems were affected during the warranty repair process. When I returned the vehicle for evaluation, the dealership stated that it would not diagnose the vehicle unless an acti.