Warnings problems of the 2023 Hyundai Santa Fe

On a clear road a sencor comes on detect comes on says detection collision. The breaks come on when you are traveling on interstate or two lane roads. When you are traveling 75 mph and breaks come on all of a sudden on the highway. We are lucky we never got hit in the back of the car going that fast. We will stop 75 to 35 mph in 10 seconds.

On two occasions, once at 70mph and once at 45mph vehicle suddenly lost power and displayed warning to check collision system, there were no vehicles close enough to warrant this. I had to limp the car to the side of the road as safely as possible and shut car off, wait a few minutes and restart vehicle to clear error and allow proper power/ acceleration again.

Three times this has happened. The instances occurred on highway 680 between pleasanton and san jose. I was going the speed limit - 65 miles per hour - as were tons of cars around me. Suddenly the car would brake, startling me because I was nowhere near another car. It frightened me a lot! I think it is the automatic braking system - either the front end collision warning or the blind spot collision warning. It could have easily resulted in an accident. I took it to the Hyundai dealership, and they knew they could not likely duplicate it. They showed me where to turn off the vehicle control (braking) for the front end collision warning and the blind spot collision warning. I have read on the internet several other parties that have experienced this - car-controlled braking while traveling at high speed with lots of cars around.

The forward collision warning system engages and slows the car, often very abruptly, when on the highway and only when cruise control is on. It happens after we have been on the highway for a few hours, thus the dealer cannot reproduce the incident. It happens a few times on every road trip and is very disturbing when there are no other vehicles or obstacles in the road or nearby. We have reported this to the dealer several times and they can find nothing wrong. I provided a photo to the dealer of the dashboard showing the cruise control on, the forward collision system disengaged, and the forward collision warning activated. Dealer states they have recalibrated the system but can replace no parts unless a part is found to be faulty. The latest suggestion yesterday from the dealer was to "get out" of the car before the issue gets worse.

I have taken my vehicle back into the dealership because my car will sometimes unlock itself, I am constantly having to check the doors to make sure they are still locked and most of the time it has unlocked itself. Most of the time I hear it unlocking as I am walking away. It is very disturbing. It also beeps as if another vehicle is going to crash into me and most of the time there aren't any vehicles anywhere near me. The phone charger does not work, I have been having issues with this from the beginning. The steering wheel also says I have to put my hands on the wheel when I have them on the wheel. I have a video of the car going a lot of rpms and it barely moved, a golf cart passed me up. The car also locks up sometimes when I am backing up. I drive my parents to san antonio for their dr. Appointments and am a little fearful of staying stranded either direction. My father is very ill and I am their driver. The dealer insists my car is the only one having these issues but I have read on reddit and other platforms of other Santa Fe's with similar issues. These issues do not occur all the time, but this does occur at the most inconvenience time.

The front collision warning/assistance system on this vehicle does not appear to be working. The dealer claims that it is working. It seems that the protocol for testing for proper function is flawed and no one is tacking ownership of this issue. They are saying that in order to test the system a near collision must be imminent and to simulate this puts the technician at risk of injury (understandable); nevertheless, I have been in situations where I should have at least received a warning and there was none. On a test drive by the service manager with me in the vehicle the front collision assistance was verified on and active. The cruise control function was tested and worked to adjust the speed of the vehicle appropriately which tells me that assistance is available. It appears that the either the collision sensor is not recognizing collision danger or the danger message is not getting to the warning trigger and possibly the assistance trigger. This situation should be reported to the appropriate department a Hyundai for review.

This same scenario has happened 3 times since I purchased this vehicle - first event at mileage of 6273, 2nd event @ 7586 miles, and 3rd event @ 12,506 miles. All events were the same - while driving, dash board light start to flash and the vehicle looses all ability to accelerate. For each event, we have been able to coast out of traffic, turn the car off & restart. Once the car is restarted the acceleration works again, but the check engine light remains on along with an error code of p065312 possible power train issue. We have been very fortunate each time that we were on a road where we were able to coast out of traffic, but if this happened on a busy interstate or hwy traveling at high speeds we could have been rear-ended. The vehicle has been to the dealership twice for service and no problems have been found. The vehicle will be returned to the dealership tomorrow for 3rd service attempt.

My horn isn't working as designed but when I push on steering wheel feels like it's cracking or breaking behind it. My front axels from factory were out of balance causing a vehicle vibration from 80+km/hr. Dealer thought it was tires not driveline. Different dealer diagnosed it as both axels in front. Issue was repaired once parts were available. Vibration still is evident but think its tires. Trying to get Hyundai to replace tires now as its consequential damage. In November 2023 I was involved in a accident where the front collision warning and assist system didn't engage properly as when it did inwas in the danger zone already. And when I applied the brakes the steering became stiff as to mimic loss of power steering. I couldn't turn out of the accident and couldn't avoid it. Have video of this on my dash cam. I have a warning light rhat comes up on my dash saying check turn signal dealership verified. They have ordered the icu junction box (fuse panel) but its been on a back order. Till February now. But no stored codes ever stay on my ecu or bcm.

When traveling along the front collision warning system is triggered even though nothing is around the vehicle. The car remains running, but there is no response from the gas pedal. I have to coast to the side if possible or stop and turn on flashers (very dangerous on interstate highway). Once safely stopped, turning off the car and then starting again reboots the system and it runs fine until it happens again randomly. The check engine light stays on for a day, but does not light up the next morning. The dealership does diagnostics, but nothing shows up as wrong. It happens so fast there is no way to take a picture or video before the warning disappears. So far I have been lucky as this has happened at least 6 times. It is dangerous and I am terrified someone will not see flashers and run into me at highway speeds.

Forward collision warning system engaged unexpectedly, braked hard to the point of smelling burnt tires. No collision imminent. Normal driving conditions. On a second occasion, stopped at a traffic light, the vehicle suddenly warned of foward parking collision. Front camera engaged and yellow warning showed.