Six problems related to engine cooling system have been reported for the 1998 Jeep Wrangler. The most recently reported issues are listed below.
1998 Jeep Wrangler exhaust manifold cracked. Contacted dealer to check about recall info after repair shop said this was common in 1997 and 1998 Wranglers. No such luck. Had it welded at my expense and have since spoken to many other folks having the same problem. Should be investigated.
Air-conditioning compressor failure air-conditioning evaporator coil failure air-conditioning refrigerant leaks and odors.
Consumer states radiator and water pump failed.
See attached letter to daimerchrysler - will be sent via mail. No safety defect listed.
The vehicle has developed an odor associated with leaking anitfreeze. 3 different trips to make repairs, no action on first trip, second trip, dealer replaced thermostat housing, third trip, dealer replaced radiator. Vehicle still has odor at different times. Seat belts have been replaced 3 times on right hand side and once on left hand side due to belts getting pinched in hardtop doors and damaging belts. Belt on right hand has had failure of seat belt inertia lock during hard stop. Electrical system: airbag light illuminated at various times, and at the same time the speedometer and tachometer failed momentarily. Fix was to clean and grease connectors. System is starting to repeat same problem, and dealer cannot find a problem. Steering column lower bushing has developed noise, after rain or onset of cold weather. Dealer states fix is to lube bushing, but problem persists after 4 dealer visits. Rear axle seals on left hand and right hand were leaking, resulting in rear wheel lockup with moderate brake application on damp pavement or sandy road surfaces. Dealer replaced both seals, but nothing was said about possible brake lining contamination or cleaning. Vehicle has had repeated water leakage from around windshield on left and right hand sides, right hand hardtop door hinge attach bolts, thru seals on cowl and around doors. Dealer has replaced all seals, rtv'd gaps, and installed updated door seals, but vehicle still leaks. Also, carpets were water damaged in front passenger area due to water leakage from vehicle body and airconditioning system. Vehicle has been kept for up to two days on two different occasions for water leaks and multiple repair complaints.
Water pump failed. Mjs.