Front Suspension Wheel Bearing problems of the 2005 Kia Motor Sedona

The contact owns a 2005 kia Sedona. The contact stated that there was a progressing noise heard near the brake system. The dealer diagnosed that the wheel bearings and hubs prematurely fractured and were held together only by two bolts. The parts had to be replaced on the front driver's side tire. The dealer was to further inspect the other three tires. In addition, the vehicle was to be taken to an independent repair shop. The manufacturer was notified of the failure, but provided no solution. The manufacturer stated that the vehicle was excluded from NHTSA campaign number: 05v232000 (wheels). The contact was uncertain as to who would repair the vehicle and if the failure would recur. The failure mileage was not available.

Vehicle has multiple brake issues. . . Replaced front rotor and pads 3 times, and replaced front wheel bearings twice. Vehicle was bought with 7,226 miles and now has 20,000 miles. The belts were replaced twice and the front suspension was fixed twice so far. Vehicle was bought at zeiser motors is st. Peters mo and the service department keeps telling me there is nothing wrong with vehicle.

The consumer owns a 2005 kia Sedona. She purchased the vehicle on 6-20-05, and twenty minutes after she drove the car off the lot, the radio quit working along with the ignition light illuminating. The consumer took the vehicle back to the dealership, and they could not service the car that day but made an appointment to come back on 6-22-05. The dealership kept the vehicle for three days. On 7-26-05 the brake went all the way to the floor and made a loud ticking noise while turning. The consumer took the vehicle to another dealership for repairs, and they resurfaced the brakes and the ignition. On 7-31-05 the brakes failed. The consumer tried to pump the brakes and they would not catch. To keep from hitting the vehicle in front, she veered to the left and ran onto the median, causing two blow outs on the driver's front and rear. The consumer had the vehicle towed to aaa, and they replaced one of the tires and placed the spare on the vehicle. There where no injuries in this accident. Also, one of the tires in the accident looked as if someone had taken a knife and cut the tire. The cut was so clean that the dealership refused to repair the tire or the rim. The consumer had to buy a new tire and rim. On 8-18-05 the van was taken back to kia,. The consumer was given a rental car. The consumer had gotten the vehicle back on August 28, 2005. On 8-19-05 the consumer received a recall letter concerning the gas pedal and braking problems. (11/30/05) the emission light had come on and smoke was seen coming from under the vehicle, there was a loud ticking sound heard when turning the steering and a coil was repaired as a result, the grease seal leaked and there was a hesitation when the vehicle kicked into gear.

The contact owns a 2005 kia Sedona. The contact stated that while driving 70 mph he felt a vibration when the brakes were applied. When he pulled over he noticed that the front end suspension had fallen apart. The manufacturer was contacted and advised her to take it to a dealer for a diagnostic test. The dealer stated that it was the contacts driving habit that contributed to the front end suspension failing. The vehicle has been repaired four times and is currently waiting for the fifth part to be installed. The dealer replaced the wheel bearings and the knuckle assembly which has fallen apart five times. The failure mileage was 105,000. The current mileage was 123,442.