Two problems related to water pump have been reported for the 2004 Kia Motor Sorento. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2004 Kia Motor Sorento based on all problems reported for the 2004 Sorento.
Traveling at 40mph crankshaft bolt broke off inside crankshaft sprocket causing harmonic balancer and belt to fall off. Also had to replace a/c comp, water pump and timing belt due to damage. 1st instance.
Summary: I was driving along the interstate at aprox. 65 mph. I heard a ticking noise and looked at the dash. No warning lights my friend asked if the car felt like it was losing speed and it was I immediatly pulled over. Moving to the emergency lane the engine stalled. None of the guages indicated anything wrong , and even after the engine failed the engine check light does not light up, none of the safety indicators light up. The vehicle has 75,000 miles only 13,000 of which I am responsible for. I am not covered under the warranty because I am not the original owner which is ridicualous in itself because the warranty should cover mileage as it states not owners. However, this problem occurred because of the fluid leaking out of the water reservoir/or possibly a failed water pump that kia knows will fail. If kia was aware of this problem and did not issue a recall, knowing that this could cause serious engine problems or death, why are they not responsible for this motor? the repairs are going to cost more than 5000 dollars this should not be tolerated. If you spend any money on a vehicle, change the oil every 3 to 5 thousand miles follow all safety recalls, you should expect more than 75,000 miles out of it. Kia should be held accountable! I have contacted a lawyer in this matter I believe that kia knows its vehicles are faulty and are waiting for the cost of lawsuits against them to increase to be more than the cost of a recall for this problem, before they do anything to rectify the issues.