Table 1 shows one common other fuel system related problems of the 2022 Kia Motor Sorento.
| Problem Category | Number of Problems |
|---|---|
| Other Fuel System problems |
The vehicle has less than 75k miles, and I am the second owner. I was driving, and the vehicle lost power. Creating a traumatic experience that could have been fatal. After kia had inspected the vehicle, I was informed that I needed a new engine and it would cost 8k or more, and my extended warranty would not cover it. Kia has current recalls for similar issues.
The fuel door actuator failed. The gas door would not open due to the actuator being seized shut, preventing access to the fuel tank. This vehicle does not have a manual release mechanism, so there was no alternative way to open the fuel door. The dealership confirmed the actuator malfunction. My family’s safety was put at risk because we were unable to refuel the vehicle. The incident occurred during extremely cold weather, with a windchill of approximately -8°f. Due to the inability to add fuel, we were at risk of running out of gas and losing heat in the vehicle, which could have resulted in a dangerous exposure situation. There were no warning lights or messages indicating a problem prior to the failure. The issue was first noticed when attempting to refuel and the fuel door would not open.
While driving from phoenix to tucson in midday traffic, the vehicle displayed a "check transmission" error message. Immediately following this warning, the vehicle experienced a significant loss of motive power while navigating a busy intersection. The car would not shift gears appropriately to maintain speed or move out of the path of traffic, which created an immediate risk of a collision. I was able to avoid an accident, but the vehicle's inability to accelerate or change gears left me stranded in a hazardous location. Component failed: transmission/transmission control module. Safety risk: the sudden loss of power in an intersection put me and other drivers at risk of a high-speed side-impact or rear-end collision. Warning symptoms: the "check transmission" message appeared moments before the failure. Inspection status: we have had the recall taken care of on January 25 , 2023 with 8810 miles at peoria kia initially. The incident happened on December 6, 2025 and the vehicle was taken to royal kia on December 6, 2025 for inspection. ".
There is a safety recall concerning fire hazard during normal operation. Kia is refusing to buyback the inoperable vehicle.
The fuel injectors, it is available for inspection. The vehicle feels like it is going to stop unexpectedly, or will not accelerate when it is suppose to, which leads me to feel unsafe driving it with my children. This is the same exact issue we had previously and it was confirmed and fixed by the dealership. The component was previously inspected and confirmed but since happening again has not been- I called the dealership and told them about the issue and they stated my vehicle was not included and they are on a month wait list. The check engine light is on. My check engine light came on, when accelerating the vehicle seems to "jump" or need a minute to catch up. It also makes a sputtering and a "tink-tink" noise when the vehicle is on. We had this exact issue moths ago and it was the fuel injector- which was replaced by kia.
I saw the kia Sorento safety recall #24v-220 for the defective high pressure fuel pump. When I look up my VIN on your site, it doesn't show this affecting my vehicle. Although my vehicle does this exact same thing. It will randomly go into limp mode and not accelerate when pulling into traffic. I took it to the kia dealer and they said it is the fuel rail pressure sensor and would be $1266 to replace. I believe this is an increased crash risk due to the loss on acceleration when the vehicle converts to limp mode and should be added to the recall you issued under #24v-220.
While driving down the highway the ev side of my phev wouldn't switch to gas. The car wouldn't accelerate past 40-50 mph and drained the remaining battery till my car shut off and forced me to the side of the road. Been to the dealer multiple times (over 4) for the same issue. They claim they recreate it and no resolution has been done.
6 different times my wife has driven the vehicle and when at a stop and restart the vehicle will not go over 25 mph even when the gas pedal is pushed to the floor. The vehicle while driving would lose power and decelerate and would only go 25-30 mph. I have two videos of it happening with her even after the previous day of the vehicle being at the dealership for the same problem. The a on the dash was not supposed to be blinking while driving according to dealership rep. I have the videos also but can’t upload them because they are bigger than allowed. I am concerned after reading reviews of other owners having the same problem but no resolution has been found. I am concerned for my family that ride in the vehicle to neighboring states for ball tournaments. Please help try to find a resolution to this issue before my family or another is injured or killed.
Hello, I own s 2022 kia Sorento. It is in dealership for the third time with same issues the other 2 times was found to need to fuel injectors #2 & #4 . My car which is also a leased car is having exact same issues again. My car has been in wyatt johnson kia in clarksville TN. Since may 22 and still state that they don't know what the problem is but they tell me to pay $900 plus taxes to fuel system to see is gasoline is problem. I have contacted dealership on many occasions and only answer is " we are working on it and we will contact me . First issue is this car is a leased vehicle and I was given no loaner car or a rental to use for the 3 weeks it has been in shop and still no answer for problem. I have contacted kia cooperate and no help or answer there either. I need help with this issue desperately. Thank you mike karan michael@karancevic. Com.
On 3/5/24, the vehicle began to limp shortly after starting it and driving a little ways. I pulled off and a majority of the lights on the dash came on. I turned vehicle off and then on, and the check engine light stayed on. I was then able to drive car as normal. The check engine light eventually went off. Service department said they were unable to do anything unless the light was on. For the next few months, upon starting the car, the auto start/stop light would flash on the dashboard. The car would limp until you turn the car off and back on. Once turned back on, the car would drive normally. On 5/20/24, check engine light came back on. Drove to dealership where I had to schedule an appointment for diagnostic testing. On 6/6/24, I had diagnostic testing done at a service department where they found that the fuel rail had gone bad.
My 2022 kia Sorento has 18k miles on it and in Feb 2024 the first incident of this issue occurred. I will be accelerating or driving through traffic (coming on and off the gas), the car will lurch several times, and then the gas pedal will stop working and the car loses all acceleration. No engine light or warning comes on. The car remains on, but it won't accelerate. I have to restart the car one or more times to get the acceleration to reengage. Since Feb 2024 it has happened 4 times, most recently on may 7, 2024. On these occasions I was driving 5-10mph, 30mph, 40mph, and once at 60mph. I have had all other required maintenance performed, checks performed, etc. I have taken it to the dealer where I leased the vehicle twice. They have not been able to replicate the issue. I'm not sure what this means, "is it available for inspection upon request" but if someone wanted to inspect it, absolutely it's available. the car completely stops accelerating, foot to the floor on the gas pedal and no acceleration happens. This happened to me on 4 separate occasions at 5-10mph, 30mph, 40mph, and once at 60mph at exactly the busiest and heavily trafficked highway in my area that has accidents on a daily basis. It's extremely dangerous. I have taken the car in twice, am scheduled for a third visit. They've kept it for multiple days both times and haven't been able to replicate the issue. the vehicle/component has not been inspected by the manufacturer, police, insurance representatives or others there were no other warning lamps, messages or other symptoms of the problem prior to the failure. The engine light does not come on. No other warning signs of symptoms before this started happening or before each failure. The first issue happened on Feb 6, 2024, then again on March 22, 2024, then again on March 23, 2024, then again on may 7, 2024.
This is the second occurrence of this issue. Suddenly all warning lights appear and the car loses power. When press the accelerator there is no revs increase and the engine misfires. I photographed the dashboard and will try to attach. The car becomes impossible to drive and my wife is scared to use it. Luckily in both cases I have been able to stop in a safe area. Switching off and restarting the engine a couple of times re-established normal engine running the issue but left the ecu warning light on.
This is the info that was given to kia : verified concern, check engine light on vehicle idling rough, scanned for codes and found code p0303 present, monitored with live data and can see heavy misfires on cylinder #3, removed spark plug and swapped to cylinder 1 and removed coil and swapped with cylinder 4, remonitored and misfire remained on cylinder 3, no fuel on spark plugs, proceeded to perform compression test, found 60 psi on cylinder 3, performed wet compression test and reading went to 120 psi, performed compression test on cylinder 1,2,3, found 90 psi in all other cylinders. Was told I would need a new engine but have now been denied it. The car has stopped on me and shakes while I drive it. It has an active recall and have been told there is no solution for it. The dealer confirmed issues and recall that is active with no remediation. Have contacted dealership as well as corporate kia and have not been able to get any resolution. This issue apperaed first with a check engine light Sep 2022 ,.
While driving the car it failed to accelerate while pressing gas. It has happened 3 times. In each case it happened within approximately 5 min of driving, twice after idling for 10-15 min. The 'hybrid system warning-safely stop and do not drive' light came on but not immediately. The engine display in the car seemed to show that the engine was not sending any charge to the battery which was rapidly depleting. Stopping and restarting the engine clears the problem. A car that won't accelerate randomly is clearly a safety risk. I have taken it in to be checked, no resolution found, unable to reproduce the problem as it is very random. First time was probably 2-3 months after purchase. My son was driving so I didn't see first hand. Second time was about 3 months after. I did have kia check for codes after that event. Nothing found. And then about 3 weeks ago. Had kia check again. Error codes not saved in the system when car is stopped. Kia maintenance can take no action at this time. They requested I try take a picture of system activity next time it happens.
Multiple times I have experienced weirdness with the transmission in my 2022 Sorento phev. One specific situation has happened to me multiple times and is a safety risk. Occasionally while stopped at a red light or stop sign with a reasonable incline it seems the electric motor fails to engage and it never switches to the ice engine either. Step by step 1 - stopped at stop sign or red light 2- release brake an hit gas 3- vehicle does not move forward no matter how hard you hit the gas (doesnt seem to engage electric or traditional engine) 4 - instead the vehicle seems like its in neutral and starts rolling backwards 5 - I slam on the brakes, and then try the gas again and everything is fine. I took it to the anderson, SC kia dealer and they just told me they couldn't replicate it. It has happened to me or my wife probably 4 times over the last year. Just wanted to report it because it feels like a good chance this is eventually going to cause a wreck.
I was pulling out to cross a highway with my 13 year old daughter in the passenger seat when my brand new 2022 kia Sorento completely lost power and we were almost t-boned by a white Ford f150 (I have all of this drivers info if needed). The screens went black like it simply shut off & I had no control of the vehicle whatsoever. I quite literally could not move my vehicle. We sat helpless, my daughter screaming bloody murder, watching a truck barrel towards us. By what could only be the grace of god, this man came to a screeching hault mere inches from my daughters windows. The car started back up like it never happened & I was able to drive almost 10 miles homes before suddenly losing power again, only this time, the screens turned black for a moment and it started back up on its own. I do not trust this car & I will be taking it back to the dealership today to demand a different car or a refund. This vehicle will cause a fatal accident.
The vehicle began misfiring while driving on the highway. The check engine light turned on. The vehicle shook violently when the gas pedal was pressed. The vehicle was unable to accelerate and required the driver to pull over on the side of the highway. This issue has presented itself several times since the original incident. After multiple visits to the dealer, the issue has not been resolved. The check engine light has been caused by code p0301 (misfire cylinder 1) as well as p0304 (misfire cylinder 4). Spark plugs and ignition coils have been replaced by the dealer, but the issue still persists. Forcing the vehicle to pull over and being unable to accelerate on the highway is risk to the driver's safety as well as the safety of other vehicles on the road. The vehicle also now struggles to start and begins misfiring when left off overnight and started cold.