Table 1 shows one common other fuel system related problems of the 2022 Lincoln Aviator.
| Problem Category | Number of Problems |
|---|---|
| Other Fuel System problems |
High voltage alert and vehicle shuts down and unable to drive and car locks up should be recall# 23s53 and NHTSA campaign # 23v-626 it has not been repaired yet and this is very frustrating has happened 4-5 times last incident happened on 11/7/2025 inside of a car wash & had to get towed.
On July 25, 2025 my 2022 Lincoln Aviator hybrid grand touring edition stalled while driving on interstate 25 in colorado springs. I lost partial control of the vehicle but was able to guide it onto the shoulder and allow it to coast to a stop. I had this vehicle towed to the dealership (where it was purchased new): phil long Lincoln, motor city in colorado springs, colorado. It has been there ever since (almost 5 months) and has not been repaired. The service department suspects that the current safety recall issued July 8, 2025 (NHTSA recall number: 25v455) was the root cause. They claim they could find nothing in the logs but they cannot rule out this as a problem. This is a life threatening issue with this vehicle and I have also been without my car for almost 5 months with repair available or capable by the dealer or Lincoln. This a very unreasonable amount of time and has been an undue burden upon me. I have sought to get a vehicle buy back under both the lemon law and the duration of this safety recall and they have refused (Lincoln corporate and the dealership). Please help.
Ford states remedy not yet available.
I have had multiple check engine light issues where the description is "malfunction indicator lamp - regulatory" and the detailed description is a problem with the evaporative emission system (evap). My cell phone app says fuel vapors are being detected. Three separate times, this check engine light has come on. Three separate times I've brought the vehicle to the dealership. My car only has about 2577 miles on it. It came back from the dealer on Monday -- and today, Tuesday, the check engine light is back on for the 4th time.
This is brand new vehicle with 3,000+ miles on it. The first day owned it, around 12-21, the vehicle would not go into drive. A warning message appeared that said 'high-voltage battery warning", "the hybrid powertrain system has detected a fault". It would also flash "full accessory power active". After some internet searches I found a thread in Ford that said "let the car sit for 20mins and it will restart". . Read more...