Table 1 shows one common engine and engine cooling related problems of the 2023 Lincoln Aviator.
| Problem Category | Number of Problems |
|---|---|
| Engine And Engine Cooling problems |
2023 Lincoln Aviator was accelerating out of toll booth to 70mph. Upon acceleration the engine hiccupped but continued to operate. Approximately 2 miles later the low oil pressure indicator and low battery indicator popped up, no prior indications existed. Vehicle stalled within 0. 5 miles as I was assessing what to do and to pull off to a safe place. I had the vehicle towed to the dealer at request of my insurance company to assess damage. Dealer found low oil and metal in engine and claimed owner failed to perform maintenance despite records of three oil changes over the last year. Dealer stopped investigation upon low oil finding and performed no other inspections. I am having the vehicle taken to another independent shop for investigation. The vehicle was involved in a low speed passenger side impact the month prior. Vehicle body was repaired but no inspection or work was completed on the engine.
I have taken my car more times than I can count for recalls in the little time that I have owned my can bought new. My work requires me to drive a lot covering 6 states. Scheduling recall repairs has become a serious issue for me in a two year old car. As it seems that most of the recalls have been fixed except one small one where it sounds like wind is blowing in and the rear view camera and display work whenever it wants. A lot of time the screen just goes dark when it’s needed the most. I just recently took my car to the dealership bec the engine light came on and my car started sputtering g while driving. Ford serviced it and within a week it did the same thing and light was back on. This time it started not cranking easy time I had to get gas. As I was driving on hwy after fuel up my car started jerking and just shut down engine. I rolled over to shoulder and it took a hand full of tries to start and I got it home ASAP. I took back to Ford and they said it was due to a fuel pump and needed to go to Lincoln. It’s been weeks now and my car is getting worse. I dont trust it to drive as I have had now two stalls and multiple hard starts where engine won’t turn over. With me on highway a lot and no recall repairs I. Sore as Lincoln said I’m not sure what to do. This is very dangerous. I was lucky I wasn’t in heavy traffic or crossing over lanes.
This vehicle continues to randomly stall upon acceleration from a dead stop. There have been numerous times this has created a near- miss accident. It has been in for service on several occasions since owning it with no resolve. This issue has been ongoing since owning it and only getting worse. Current mileage is approx 23,000 miles.
I did an inspection of my exhaust system and saw numerous carbon deposits along both pipes at different joints. I brought this to the attention of the dealer and they repaired only one (1) leaking joint at the tailpipe. They told me the other leaking joints are normal and are of no concern. I have a video, pictures and the dealer inspection/repair forms from two (2) different service dates.
The contact owns a 2023 Lincoln Aviator. The contact stated that after parking the vehicle in the garage, the garage became extremely hot, and the fans underneath the vehicle activated. The contact opened the garage. The vehicle was towed to the local dealer, who was unable to determine the cause of the failure. The vehicle was not diagnosed or repaired. While driving at an undisclosed speed, the “service engine now” message was displayed. The powertrain control module had detected a fault with the high-voltage system, and a message was displayed. After researching, the contact linked the failure to NHTSA campaign number: 23v626000 (electrical system); however, the VIN was not included. The manufacturer was not contacted. The failure mileage was approximately 20,990.
Once again, my vehicle exhibited immediate and sudden power loss while at highway speeds. Ironically, I was in transit to my dealer for the third time for this issue within my vehicle's 3,000 miles. This is incredibly unsafe at any speed, especially at highway speeds without warning. An uncommanded slowdown without any response from the accelerator pedal, and a warning on the gauge cluster stating "vehicle is slowing down". Cruise control at this time was not operational in the vehicle (another issue) and I was using my foot to control the speed. Additionally, the bluetooth connection was not functioning, the navigation screen nor map would even load, and I was unable to use cruise control due to an error message "cruise unavailable". We get a separate Lincoln Aviator for a loaner, and not only does reverse park assist not work, the rear camera doesn't function, either. These cars are dangerous and need to be recalled immediately and taken off the road. We plan to sell/trade ours as the soonest possibility and incur whatever financial burden that may come with it. It's not worth my family's safety, or that of someone else.
Went to get in it this morning, and said no key was detected. Okay, whatever, we'll use a backup code. The screen never prompted for a backup code. We had the key inside the vehicle, so we use the Lincoln way app to start the car and figured we can get it going from there. Nope, the car was running and everything was going, yet it won't allow us to select drive, reverse, or neutral. Sat there for a bit, fumbling around and nothing worked to get the vehicle in motion. We finally hit enough buttons for the vehicle to shut off, we got out, locked the doors, plugged it in, and just allowed it a few minutes to reset. Notta. Got all this on video. I finally had to pop the hood and use the freaking 2021-2023 explorer / Aviator hybrid vehicle emergency response guide to kill 12v power to the thing. After all that, it allowed us to get in and drive normally. However just a few hours later. . . 2,600 miles on the odometer and we were driving approx 55mph and the Aviator engaged the parking brake for about half a second. Nasty noise, huge bucking from the chassis, and just a split second of extreme confusion and wondering wtf. The red "park brake" was illuminated on the dashboard, and everything seemed normal afterward. However, immediately after that incident it then disabled adaptive cruise control via a message on the dashboard (no cruise worked). We drove home without further incident, called the dealer, and they stated to call Lincoln roadside assistance, get it towed back to the dealer that it was just a few days ago, and they'll deliver a loaner to us. A few hours later, it's on the tow truck. This is the second time this vehicle has placed us in danger. The first issue I'll report after this is submitted. Thank you.
The rear camera is janky, the collision alert fires off at random times, and now, the main safety issue! received a huge red triangle on the hud and nav screen stating that the "vehicle is shutting down" and then poof, the damn thing shut down immediately without warning. The message was on the hud and nav for about a second and a half and it died. Thankfully we were at surface street speeds of around 30-35 and I was in command of the vehicle. This issue has been reported on other grand touring models of the Lincoln Aviator where people are at higher speeds, such as the highway or expressway. That said, this is my wifes main vehicle and I am terrified, as well as she, to have her driving this at all hours of the day responding to emergencies at her hospital. Please help us all that own this vehicle.