Seats Problems of Lincoln Aviator

The contact owns a 2023 Lincoln Aviator. The contact received notification of NHTSA campaign numbers: 25v407000 (structure), 25v393000 (seats), 25v455000 (fuel system, gasoline); however, the part to do the repair was unavailable. The dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. The VIN was not available.

See all problems of the 2023 Lincoln Aviator 🔎.

What component or system failed or malfunctioned, and is it available for inspection upon request? the 2nd row seats have an electrical switch to slide and slightly fold the seat for entry to the 3rd row. This switch seems to get stuck and will randomly slide and tilt the seat forward while driving as well as while stationary. While driving, the seat can hit the back of the driver seat very hard and cause disorientation. The vehicle has not yet been reproduced or inspected by a dealer or other service center. The vehicle has not been inspected by manufacturer, police, insurance rep, or any other organization. There were no warnings or messages prior to failure, this car I purchased used and the symptom was presenter as soon as I drove off the lot.

See all problems of the 2022 Lincoln Aviator 🔎.

Safety issue that occurs while driving that nearly caused me to drive off rd multiple times, has been reported by others on Lincoln forum & appears to be pervasive safety issue. 2nd row seat automatically folds down, moves up & slams into back of drivers seat, even while driving. Happened sev times, twice at night while on hwy doing 70mph. Had to pull off hwy, push seat back & relatch. 2 hrs later, it happened again. Previously, dealer looked at but couldn’t id cause. Now, tech reports button on top of 2nd row seat was stuck down even though it ‘looks’ like it’s not. Some have had dealer replace the button but after a few mos the new one gets stuck. Others report theirs is stuck down & since car’s out of warranty, they need to pay to fix it (to avoid an accident). Urging NHTSA to investigate as this is a significant safety concern.

The contact owns a 2023 Lincoln Aviator. The contact stated that while the vehicle was parked and attempting to press the button to raise the level of the third-row seats, the contact and her daughter were ejected from the seats. The contact stated that there were no injuries sustained. There was no warning light illuminated. The contact stated that there resistance while attempting to raise the seats. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 18,000.

My vehicle has heated seats. This week, when I was using the heated seats, I noticed a burning sensation on my left buttocks. I later discovered a burn hole in my seat (bottom left) and a matching burn on the coat I was wearing (bottom left). I am reporting this incident I because I believe there is a defect of the heated sweats in my vehicle that could lead to severe burns to passengers.

See all problems of the 2021 Lincoln Aviator 🔎.

The contact owns a 2022 Lincoln Aviator. The contact stated that while driving at various speeds, the vehicle would hesitate upon depression of the accelerator pedal without warning. The vehicle was taken to a dealer where they failure to diagnose the failure. The contact then received 3 recall notices for NHTSA campaign number: 25v407000(structure); NHTSA campaign number: 25v393000(seats); and NHTSA campaign number: 25v455000(fuel system, gasoline). The dealer was notified of the recalls and the contact was informed that the parts for the recalls were not available. The manufacturer had yet to be notified of the failure. The vehicle was notified repaired. The failure mileage was unknown.

I purchased the auto on Aug 24, 2019. I have encountered 5 issues with the vehicle so far - 3 mechanical and 2, cosmetic. I'll focus on the mechanical. Beside the pending recall, I am experiencing the following: 1) the passenger seat in front row lacks the motor for the massage function. Lincoln has now taken over 2 months to repair due to lack of part. 2) the electrical parking brake comes on while driving occasionally. 3) the vehicle camera gets distorted when switching car on. Happened twice, last time it happened was a week ago 11/12.

See all problems of the 2020 Lincoln Aviator 🔎.