general problems of the 2019 Mazda CX-5 - part 2

In August 2025, we brought our Mazda Cx-5 (non-turbo engine) to a Mazda service center and paid nearly $3,000 for repairs, including replacement of belts and other related service. Despite this, we continued to experience a burning smell from the vehicle. Shortly thereafter, the problem escalated — the burning smell persisted and smoke began to appear. Mazda is now demanding an additional $4,500 to replace a cracked cylinder head. This defect must have been present when the car was serviced in August, and the initial repairs failed to identify or correct it. While there is an NHTSA technical service bulletin for the turbo version of this engine, there are numerous complaints online about the same defect in the non-turbo model, which is what we own. This indicates that the problem is not isolated. Mazda should be held responsible for this safety issue. A cracked cylinder head that leads to burning smells and smoke is a serious hazard that could cause engine failure or even fire. Consumers should not be forced to spend thousands of dollars on repairs for what appears to be a widespread defect and when our vehicle has only $50k miles and it should last for the life of the vehicle.

The contact owns a 2019 Mazda Cx-5. The contact stated that while driving 30 mph with a toddler occupying the rear seat, the contact noticed smoke and an abnormal burning rubber odor coming through the vents. The contact pulled into a gas station and then pulled into a nail salon parking lot. There was no warning light illuminated. The contact was able to drive to the residence, where an independent mechanic inspected the vehicle and found an oil leak, and the mechanic diagnosed that the cylinder head had cracked. The vehicle was taken to the dealer. The dealer informed the contact that the repair could not be covered under an unknown extended warranty because of the type of engine. The manufacturer was notified of the failure and informed the contact that the repair could not be covered under goodwill assistance because the oil changes had not been mainly performed by the dealer. The vehicle was not repaired. The failure mileage was approximately 83,000.

Drove 39 miles, around ~55 minutes. Parked the car, realized that I parked a little too far from the spot, car just stalled while rolling. Pressed accelerator, nothing. Turned off the car, tried to start again, it cranked but didn't start. Had to tow it to the nearest mechanic (total of ~2 hrs until my car got picked up and dropped off), mechanic calls me and tells me my car started fine. I'm thinking it could be 5321k recall but not sure as my VIN is not in the recall nor did I get any recall notice. What component or system failed or malfunctioned, and is it available for inspection upon request? - no idea. How was your safety or the safety of others put at risk? - got stranded for hours in the parking lot. Has the problem been reproduced or confirmed by a dealer or independent service center? - no has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? - no were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? - yes, fuel cap like icon and check engine light were on when trying to start the car after it stalled. The car would crank but not start.

Confirmed cracked cylinder by dealership, led to dumping of oil while vehicle was in motion on the highway. Vehicle/engine could have caught fire at any moment. There were no engine warnings that appeared on the dash. This is consistent with other Cx-5 complaints on NHTSA. Vehicle had 55,000 miles on it at time of incident, and needed $8,000 worth of repair. Please recall!!.

Cracked/leaking cylinder head on my 2019 Mazda cx5. It is understood that Mazda has extended warranty for the turbo model (csp11) of this car, but not the standard engine, even though they both are displaying the same issue in many 2019 cx5s. Quoted at $6000 for a vehicle under 90k miles. Issue needs to be escalated.

Dealership service department found a cracked cylinder head. This issue has been reported to NHTSA by Mazda. The car is being serviced and this issue was found. I’m attaching photos and also report from dealership l.

Cracked cylinder head.

Timing cover oil leak. This is the same issue reported in technical bulletin #01-006/23 issued on 04/26/2023. There is oil leaking and the engine is smoking. No engine warning lights or other messages appeared. My car is a 2019 Mazda Cx-5 and has 31,954 miles. This problem has been confirmed by both an independent mechanic and the dealer service center. On 08/22/2025, I took my vehicle to dealer service for the repair. I also submitted a ticket to Mazda care for review of the case.

For the 3rd or 4th time since I have own this car I experienced a loss of acceleration when attempting to make quick acceleration while attempting to merge with traffic. Acceleration is fine around town where quick acceleration is not appropriate. But the first attempt to merge with flowing traffic the car will slowly accelerates to about 30 mph and no more regardless as to position of accelerator pedal. On all occasion this bad behavior has this first drive of the day - going to work in the a. M. There is often a warning message indicating the safety radar is not working due to limited visibility which is a very common warning in the a. M.

The engine has an oil leak from the head. It is a common problem with this year and make. It is a manufacturer's defect called a porous head where oil leaks through the casting not a seal. I've already spent $2000 to repair but still leaks. Oil leaks onto the exhaust and smokes causing fumes in the inside of the car and can be a fire hazard. Mazda is well aware of the problem but has yet to address it.

My vehicle has 64k miles and has had regular maintenance - oil changes, etc. It has recently developed an oil leak. I took it to the dealer today & they said the cylinder head and gasket needs to be replaced. My car has not overheating or even run warm. I understand there are 2019 Cx-5s that have had a casting issue with cylinder heads. I feel sure that’s what the issue is here yet they want almost $6k to repair my vehicle!.

The contact owns a 2019 Mazda Cx-5. The contact stated that while operating the vehicle, the message that the engine oil level was low was displayed. The contact stated that oil was added to the engine; however, the next day the message reoccurred. The contact stated that later while the vehicle was parked, the contact discovered an oil leak underneath the vehicle. The vehicle was driven to the local mechanic who confirmed oil leaking from the engine, but the cause of the oil leak was not yet determined. The local dealer was contacted, and a service appointment was scheduled. The cause of the failure was not yet determined, and the vehicle was not yet repaired. The manufacturer was not contacted about the failure. The failure mileage was 96,600.

Just got diagnosed with cracked cylinder head. After looking on social media, it appears this is a thing for the model years 2018 and 2019. Bad casting? anyway I believe this should be a voluntary recall to correct such a flawed engine. I bought this new from a Mazda dealership and kept it up to date with service only through the dealer. The 60 month/60,000 mile drive train warranty ran out last July. However I only have 50,000 miles on the car. . . Babied.

Unknown. Ticking noise on engine.

At 30,000 miles car began leaking oil severely and was told that the engine block was cracked and needed to be replaced. There are numerous complaints of this same issue online happening just after the warranty has expired. The cost of repair is $6000.

The contact owns a 2019 Mazda Cx-5. The contact stated while the vehicle was parked, the contact discovered an abnormal odor coming from the engine compartment. No warning light was illuminated. The vehicle was taken to a dealer where it was diagnosed that there was a cracked cylinder head and that the cylinder head needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 26,000.

Cracked cylinder head. Major oil leak. Oil light came on but then turned off. No other warning light. No engine light came on. The vehicle was taken to the dealer for diagnosis.

The engine cylinder head cracked before the vehicle hit 50,000 miles. This caused oil to leak and burn in the engine compartment, leading to a burning smell coming into the cabin. Once enough oil had been lost, I got a low oil pressure light. I immediately pulled over and noticed white smoke was coming out from under my hood, and the smell of burning oil was quite strong. The problem has been confirmed by my Mazda dealer. The vehicle has not been inspected by manufacturer, police, insurance. Just the dealer. The vehicle is currently at the dealer, and the cylinder head would need to be removed for inspection if requested. The smell of burning oil was the only early symptom, though I did not recognize it at the time.

I had my vehicle looked at and found a cracked cylinder head on #3 and did some research of people having the same issues. I was driving when the vehicle started smoking it turns out the oil coming out of cylinder #3 flows down the driver and passenger side behind the exhaust manifold which can lead to a fire. My car only has a little over 80,000 miles and this should not happen around that low of a mile vehicle. I believe this is an issue that needs attention.

The contact owns a 2019 Mazda Cx-5. The contact stated that while driving up on incline at 45 mph, the engine shut off with the check engine warning light flashing on the instrument panel. Despite the failure, the contact was able to pull the vehicle off to the shoulder of the road. Due to the failure, the vehicle was towed to the residence. The following day the vehicle was towed to an independent mechanic; however, the mechanic was unable to duplicate the failure. The mechanic replaced the spark plugs and the ignition coil. The mechanic referred the contact to the dealer for additional assistance. The contact drove the vehicle to the dealer with an abnormal rumbling sound coming from the vehicle. While at the dealer, the dealer was unable to determine the cause of the failure. The contact was provided an estimate for repairs unrelated to the failure. The manufacturer was notified of the failure and provided a case number. The vehicle was not repaired. The failure mileage was a 129,000.

The cylinder head on my 2019 Mazda Cx-5 failed prematurely due to a known defect. The vehicle is currently at fred beans Mazda in mechanicsburg, PA, where the issue has been diagnosed and confirmed. The defective component is available for inspection upon request. This failure created a serious safety risk due to an oil leak, which led to smoking from the engine bay and a potential fire hazard. If the oil had ignited, this could have caused severe vehicle damage or injury. Additionally, the failure could lead to a sudden loss of power while driving, increasing the risk of an accident. The problem has been reproduced and confirmed by the dealership, and Mazda has been contacted regarding assistance. They have acknowledged the issue but have not provided full coverage for the repair. Prior to the failure, there were no warning lights or messages. The only symptom was an oil leak, which led to smoke coming from the engine. This issue appears to be a common problem with this model, and Mazda should take responsibility for addressing it properly before it causes serious harm.

This concerns a 2019 Mazda cx5 with approximately 52,000 miles - the engine of this vehicle is the 2. 5l naturally aspirated version. Driving the vehicle with the hvac system on resulted in a burning oil smell coming through to the cabin. Upon owner inspection, engine oil was seen as coating the underside of the vehicle in various areas. The oil pan drain plug and oil filter were both found to be tight and not leaking oil. The vehicle was taken to a nearby Mazda dealership for inspection on 2/26/2025. On 2/27/2025, Mazda technicians state that the cylinder head on the vehicle engine requires replacement. Replacement is quoted to be in excess of $5000. Reviewing the issue online shows numerous similar cases of engine cylinder head failure. This vehicle comes equipped with cylinder deactivation which seems to have a higher rate of failure regarding cylinder heads and a potential design flaw with cylinder heads manufactured in a time frame of 2018-2020. Leaking oil could potentially start a fire as the oil drips onto the exhaust manifold when the car is at operating temperature.

The cylinder head in the engine cracked while I was driving. The vehicle was leaking oil profusely and was down a quart after the oil had been changed the week prior. There were no warning lights or indication and I had just had the vehicle in the dealership the week before. I'm a disabled driver that requires hand controls so if I needed to exit the vehicle and move away from it it would not be possible. It's been at the dealership since 2/24/25. I have found numerous other people that have experienced the same issue online.

Valve cover develops crack causing significant loss of oil resulting in seizing of engine with the potential of serious accident and potential loss of life.

Engine has a crack in the head, well under 100,000 miles. It's a known defect but Mazda refuses to do anything about it. It is currently a very expensive paperweight sitting under our carport.

While driving the vehicle, I started smelling a burning smell about 10 days ago (2/17). I also felt a slightly reduced engine performance and could see the car emitting smoke from the engine bay. I had no warning lights on my dash. For all I know, the engine could've blown while I was driving on the road. Upon taking the vehicle to the dealership 2 days ago (2/25), they informed that my car has a cracked cylinder head, and there was no apparent reason why this would happen. The vehicle has only been inspected by the dealership thus far and I was quoted $5,700 to fix the issue. Upon looking up the problem, I see this is a common issue, with many having experienced it before, but no tsbs issued for this. There is a csp issued for vehicles of the same year, but limited to the turbo version on the engine. Unfortunately, I do not have any warranty on the car currently.

I hope this message finds you well. My name is [xxx] , and I am the owner of a 2019 Mazda Cx-5 purchased as part of the certified pre-owned (cpo) program. I am writing to formally address two concerning issues related to my vehicle’s warranty coverage and its safety. 1. Warranty coverage for drive belt tensioner: during a recent visit to your dealership, I was informed that the drive belt tensioner on my vehicle is not covered under the warranty. This contradicts the coverage listed on your official Mazda cpo warranty, which specifies that the limited powertrain warranty includes the engine, timing chain, tensioner, and associated components. The drive belt tensioner is clearly referenced in this section, yet I was told it falls under wear and tear and is not covered. I kindly request a detailed explanation regarding this discrepancy. I believe the information I was given does not align with the warranty’s stated coverage, and I am concerned that the dealership is not honoring the terms of the warranty as outlined on your website. 2. Ongoing noise issue: additionally, my vehicle has been making an unusual noise, which I reported during my visits to two separate Mazda dealerships. Unfortunately, despite multiple attempts to diagnose the issue, neither dealership has been able to identify the source of the noise. This situation has left me feeling unsafe while operating the vehicle, as I am unsure of its origin or potential impact on my vehicle’s performance or safety. I would appreciate it if you could escalate this matter and offer assistance in determining the cause of the noise, as well as ensure that all components of the vehicle are functioning properly. The lack of resolution is not only inconvenient but also concerning from a safety perspective. Request for resolution: I trust that Mazda values its customers and will make every effort to resolve these issues in a timely manner. I respectfully request that the drive belt tensioner be covered und information redacted pursuant to the freedom of informa.

Oil started leaking while car was idling causing smoke to enter the cabin as well as all under the hood. Car was undriveable at this point. She was lucky there was no traffic. Car had to be towed and cylinder head was cracked. Mazda has a known faulty cylinder head problem they have refused to fix and this caused a safety issue. Vehicle will not be able to be inspected as we had it towed to get fixed immediately. The service center did confirm this is the issue and there were no prior issues before this.

I own a 2019 Mazda cx 5 and it has 78,000 miles. I noticed smoke coming from the engine and a lot of oil leaking on the ground. I brought the car into my independent service center and they confirmed that there was a crack in the engine cylinder head. There is a tsa # sa-031-21 on this problem. I feel that my safety was at risk, since the engine could have seized while driving. This vehicle is available for inspection upon request. No warning lamps or messages were displayed, however there was a strong odor of burning oil. This problem occurred on 1/9/25 and it has been in the service center since.

My 2019 Mazda Cx-5 suddenly developed a major oil leak within the last 7 days. My car has only 44,350 miles and I have had all scheduled and required maintenance completed timely, including oil/filter changes, coolant level checking and maintenance, etc. I took the car to an independent mechanic who diagnosed the problem as a cracked cylinder head. I then took the car to a local Mazda dealer who confirmed the diagnosis and informed me that there would be no warranty coverage as my 60,000 mile/60 month powertrain warranty had expired 60 days earlier. Some two years earlier my car's check engine light came on and overheated. I took it to the same local dealer, who replaced the coolant control valve & related components. In November 2024 I received a "warranty extension program" letter from Mazda about the same fail-safe thermostat problem. I believe this is relevant and related to the cracked cylinder head since almost all instances of a cracked cylinder head are due to engine overheating. This issue put me at risk as I was close to driving the car with no oil and oil leaking heavily onto very hot engine components that could have resulted in a fire. I am now facing repairs to this car between $4,800 and $6,000 and given the faulty/defective cylinder head from Mazda, I could face this safety issue again, as it will be replaced with a similar cylinder head from Mazda!.

As I was driving, a burning smell emanated from the car. There were no check engine lights on. When I pulled over, I saw a lot of smoke coming from the engine. I checked the oil level and it was above the minimum line bit just barely, even though my husband had just done an oil change on it. I refilled the oil and continued on my trip. The problem repeated for several dqays until I got home and took it to the Mazda dealership. They reported the following: "cylinder head assembly: oil leaking out of back of head, recommend replacing cylinder head and related gaskets. The cylinder head sits above the cylinders on top of the cylinder block. It closes in the top of the cylinder, forming the combustion chamber. This joint is sealed by a head gasket. In most engines, the head also provides space for the passages that feed air and fuel to the cylinder, and that allow the exhaust to escape. " this service is $5600! my car only has 80k miles on it. This is a safety issue because there was no warning. No check engine light appeared and there was no warning.

Engine block cracked, passenger cabin filled with noxious odder. Vehicle was suddenly leaking oil at high rate.

The 2019 has a creaked cylinder with 40000 miles on it. This is a problem with that has been happening. We are 4 months out of the warranty with may 2024.

My Mazda Cx-5 was found to have a cracked cylinder in the engine and was profusely leaking oil. When I spoke to the dealership they denied seeing this regularly, however, upon doing research on reddit, it is found to be more pronounced than indicated. There was no known cause indicated, however, on reddit it appears that the original casting done in mexico maybe the culprit because it is so thin and causes it to crack between 40-50k miles. There is no other sign or warnings, besides an obscene amount of oil leaking. The failure of this could cause the engine to fail while driving. This is a significant risk.

Vehicle has 40k after a oil change noticed oil spots on pavement took it back to the garage that did the task, was told that the leak was near cylinder #2. Called Mazda customer service and was informed that my warranty expired in may of 2023. My mechanic called Mazda parts to get the price of cylinder head and was told that they had a run on cylinder heads due to defective heads coming from the factory, should be a recall on the Mazda.