Mazda MPV owners have reported 12 gasoline fuel system related problems since 1996. Table 1 shows the 6 most common gasoline fuel system problems. The number one most common problem is related to the vehicle's gasoline fuel system (4 problems). The second most common problem is related to the vehicle's tank filler pipe and cap (3 problems). For details of each of the problem category, use the links in the table.
| Problem Category | Number of Problems |
|---|---|
| Gasoline Fuel System problems | |
| Tank Filler Pipe And Cap problems | |
| Tank Assembly problems | |
| Gasoline Storage problems | |
| Fuel Injector problems | |
| Fuel Injection problems |
Since new, hesitates between 40-50 mph, causing sudden loss of power, high rpms but no acceleration. Removing foot from gas van sometimes recovers. Has had transmission control module replaced as a result, then ignition coils were blamed and those were replaced one by one, sometimes more than once, Read details...
I bought this car for 6 months, the engine light on twice, didn't fix it first time, the advisor said the gas tank cap is not close tight enought. Couple of days later, the engine light is one again, this time they found control system incorrect flow, small leak, hose off of purge valve at air Read details...
Tl-the contact owns a 2006 Mazda Mpv. The contact stated whenever he fills up with fuel the fuel spills back over. The dealer replaced the filler tube twice and the fuel tank once and since these repairs the failure continues. The fuel keeps spilling out on him. Read details...
Not a complaint-merely a questionable vehicle safety/design inquiry: I bought a 2003 Mazda Mpv in December. Recently, while under the vehicle doing an oil change, I noticed a troubling design in the gas tank location. It is right up against the door sill/rocker panel area on the driver's side. Read details...
Mazda 2004 Mpv with just under 68,000 miles has 3 fuel injectors(cel) replaced by local mechanic- 2 weeks later jerky misfires with cel required #5 coil replaced by dealership, less than a month later #4 coil replaced by local mechanic in town we were vacationing in-no cel, now same jerky misfires Read details...