Seven problems related to other fuel system pump have been reported for the 2007 Mercedes Benz C230. The most recently reported issues are listed below.
Nhtsa recall 08v303000. My car fuel gauge misreads what is not there. Stalls and not restart without tapping the fuel pump. Fuel light indicates fuel sensor need to be replaced. After paying $327. 00 still continues to malfunction. Stopped several times on street and parking lots. Towed several times. Refuses to start without notice. Harness for it not found. Impact of accident lost fuel. Since accident towed three times stalled and towed once and twice by Mercedes Benz. Replacement cost $1051. 00.
Tl- the contact owns a 2007 Mercedes Benz C230. The contact stated that there was a strong fuel odor in the vehicle. There was no warning indicators illuminated during or after the failure. The vehicle was taken to the dealer where it was diagnosed that the fuel pump was fractured and the descending units malfunctioned and needed to be replaced. The vehicle was not repaired. The vehicle failure mileage was approximately 106,000. Kh.
Strong raw fuel odor was noticed after fill up on multiple occasions. Investigation found that both the fuel pump housing and the fuel sender housings were cracked allowing raw fuel to leak out. This is exactly the same as the e class recall. This recall needs to be extended to include the c class as well as this car has an identical failure mode. I found this issue was previously reported, and would like to second this noted issue. For many months have noticed strong fuel smell from left rear wheel well. Mb dealer confirms above similar diagnosis and approximately 1k repair cost, gas is leaking out and pooling on top of sender unit.
Car would not start after fill-up. Removed back seat to find a puddle of gas on the fuel pump module (drivers side). Plastic on pump cracked, shorting out module. Big safety hazard.
Strong raw fuel odor was noticed after fill up on multiple occasions. Investigation found that both the fuel pump housing and the fuel sender housings were cracked allowing raw fuel to leak out. This is exactly the same as the e class recall. This recall needs to be extended to include the c class as well as this car has an identical failure mode. I found this issue was previously reported, and would like to second this noted issue. For many months have noticed strong fuel smell from left rear wheel well. Mb dealer confirms above similar diagnosis and approximately 1k repair cost, gas is leaking out and pooling on top of sender unit.
After I fill the tank up with gasoline the car smells like gas! especially in the rear on the inside and out. Huge safety and environmental issue. Seems to be very common with this year and should be made a recall. Fuel vapors are unhealthy to be breathing and should not be release into the atmosphere. Not to mention my gas mileage has decreased! it should be a recall and not a "wear and tear" issue because the car cannot even register the issue no cel (check engine light) appears but yet the fuel is obviously leaking. I read into it and many people say it has to do with cracked housings on the fuel pump and sender? please make this a recall!! huger safety concern what if I crash and the car ignites from the inside!.
Engine failed to start; would crank, but would not start. Key had to be returned to off position to stop cranking action. Maintenance supervisor claims teh fuel pump was at fault.