Other Fuel System Hoses Lines/piping, And Fittings problems of the 2011 Mercedes Benz E350

One problem related to other fuel system hoses lines/piping, and fittings has been reported for the 2011 Mercedes Benz E350. The most recently reported issues are listed below.

1 Other Fuel System Hoses Lines/piping, And Fittings problem

Failure Date: 12/16/2018

Fuel tank was filled until automatic nozzle shut off was activated. Vehicle was driven home approx 3. 5 miles and parked in the street. Next day there was a puddle of fuel approx 2 ft x 2 ft on the pavement and under the car, just forward of the right rear tire. I watched for several minutes, and noticed it was still leaking at the rate of one drop approx every 2 mins. Thinking that perhaps a hose between the fill port and fuel tank was leaking, I drove it for approx 15 mins, hoping to utilize enough fuel to lower the level of fuel in the tank and/or hose. I returned home and parked the car again. The car was still dripping fuel at the same rate. I moved the vehicle into my driveway to try to ascertain the source of the leak. I jacked it up, removed the right rear wheel, but still couldn't see the fuel tank clearly. So I also removed the plastic windage panel, which covers the undercarriage of the body from front to rear wheel. It was completely fuel soaked at the rear. I also noticed that the exhaust pipe, a possible source of ignition, is routed directly in back of the fuel tank. I researched this problem on the mercedes forum website, and discovered that a defective fuel filter flange, which eventually cracks and allows fuel to leak and puddle on top of the tank, is a common problem. However, it appears that the "build date" of my particular car (08/10) is not covered by mb campaign 2013020002. Yet, the problem is identical to the vehicles which are covered, and received an extended warranty.


Other Other Fuel System related problems of the 2011 Mercedes Benz E350



E350 Service Bulletins
E350 Safety Recalls
E350 Defect Investigations