Table 1 shows one common other fuel system related problems of the 2015 Mercedes Benz ML350.
| Problem Category | Number of Problems |
|---|---|
| Other Fuel System problems |
The failed/malfunctioning component appears to be the fuel pump controller / fuel pump control unit, and possibly the fuel pump system. The mercedes-benz dealer identified water/moisture-related damage and corrosion at the fuel pump controller area. The failed component should be available for inspection if the dealer preserves the part during repair. I have requested that the dealer not discard the damaged component. My safety and the safety of others were put at risk because the fuel pump controller is related to fuel delivery. If it fails, the vehicle may not start, may lose fuel supply, or may stall while driving. This creates a safety risk, especially if the vehicle stalls in traffic, at an intersection, on a highway, or during normal driving. The problem has been confirmed by a mercedes-benz dealership. The dealership diagnosed water/moisture damage to the fuel pump controller area and provided an estimate of $768. 22 for fuel pump controller replacement, plus $244. 88 for the inspection fee. The dealer also indicated that this was the first inspection and that the fuel pump itself may also need further inspection or may have related damage. The vehicle/component has been inspected by a mercedes-benz dealership. Mercedes-benz USA / the manufacturer’s representative has also reviewed the case through its goodwill process, but they refused to treat it as recall-related coverage. To my knowledge, the vehicle has not been inspected by police or insurance representatives. Prior to the current failure, the vehicle had starting/no-start related symptoms beginning around the middle of 2023. The engine could not start successfully at times. I do not recall receiving a clear warning lamp or message specifically identifying the fuel pump controller before the failure. However, the symptoms were consistent with a fuel delivery problem, and the dealer later confirmed water/moisture corrosion damage in the fuel pump controller area.
My viechle is loss of propulsion without warning on the freeway last week on a raining day. After brought the car to west covina dealer inspected the car is leaking water that has entered the spare wheel well, the accumulated water could intermittently contact the fuel pump control unit caused loss propulsion. And there are some circuit boards and wires damaged due to a water leak and not drive able. The west covina mb dealer is refuse to fix until mbusa responsible for the cost. Please help what other option we have about this issue?.
There is a recall for this significant safety risk. I contacted my local Mercedes Benz about recall remedy on 6 January 2023 and they confirmed the recall and said mb would issue steps to get this taken care of in the beginning of February. It is now 18 February 2023 and this has not happened and I have received no communication from mb and yet the safety risk still exists and could be life threatening.
Going to work in the morning and pulling out of the garage my foot was on the brake not the accelerator in reverse suddenly the car surged by itself while I had my foot on the brake. The car went in reverse very fast hitting our side concrete side wall. (the distance is about (28ft) the impact was so hard that the passenger window was completely broken and the passenger side of the back frame of the mercedes was smashed. It happened so fast that I lost control of the vehicle I could not stop the car the brakes did not work. After I hit the wall I was jolted forward and I smashed the front end of the car with the garage. The car finally stopped in the middle of the driveway. Again, I did not put the car in drive when I was jolted forward the car went forward from the impact of the hit from the wall and I did not put my foot on the accelerator.