Two problems related to gasoline fuel system have been reported for the 2002 Mercury Sable. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2002 Mercury Sable based on all problems reported for the 2002 Sable.
Car not handling properly. Brakes squealing. Very poor gas mileage. Car riding lower in back. Sounded/felt like I was riding on a flat, tire pressure was down, but not badly (3 lbs). Took to mechanic for tuneup. Advised rear tire bad with flat spots. Purchased tires to be installed. When mechanic pulled tire/wheel to install, noticed rear spring was broken. Pulled tire/wheel from other side. It too, was broken. One break was new, the other older as ends were rusted over. There are rub marks and wear on the rubber covering over both springs as well as the coating coming off. I have the broken springs and have taken photos that show brakes and discoloration. Two (2) new tires, two (2) rear springs and alignment cost $614. 68. I frequently have my grandchildren with me. Either one or both of them could have been severely injured has the pieces come through the seats.
For about five months there has been a fuel smell entering the passenger cabin. About two weeks ago the vehicle blew up and burned the driver. The fire was extinguished by the fire department.
| Fuel Pump problems | |
| Gasoline Fuel System problems | |
| Fuel Hoses Lines/piping And Fittings problems |