Table 1 shows three common gasoline fuel system related problems of the 2001 Mitsubishi Montero Sport.
| Problem Category | Number of Problems |
|---|---|
| Gasoline Fuel System problems | |
| Tank Mounting problems | |
| Tank Assembly problems |
I have a 01' Mitsubishi Montero Sport xls 3. 0l as of the last week in March I had a problem with my a/c and call auto repair shop to make a appointment. To my surprise the Mitsubishi/Saturn shop, the place that I had taken it to 6mths to a year be4, my oxygen sensor to be replaced and some other things, was gone out of business. So I call where I purchased the vehicle from, and was told that I could goto a licensed mechanic shop to get my a/c fixed, oxygen sensor had default again, but it still had warranty on it with the previously shop so the recent shop could not replace it and I also still had warranty coverage with the credit union that I pay monthly payments to. So I called the warranty group, and the warranty group paid for a/c to be fixed and I only had to pay 100 deductible. I received my SUV back about a week later, then I noticed a knocking within the motor so I went back to the repair shop, and was told that I needed a oil change, but I just recently had a tune-up and oil change. So I knew that I didn't need a oil change. The shop could not determine what caused the knocking noise, but on 5- 23-10 my SUV had malfunction this time my crankshaft,pulley,rods had separated and the only thing that was holding my engine together was the main bolt. So I got it towed back to the repair shop and I had to get my engine replaced. The warranty group paid for the pre-used engine, and I received my SUV back on 6-11-10. I did not drive my truck no more then to my home and parked it in my yard, but on that Tuesday June 15, 10 I went into a furniture store for about 20 mins. And left my a/c on, came back and only the fan was blowing, so I cut-off my SUV and waited for 5mins. Cut my SUV back on and drove back home with no problems. I had a appt on wed. 06-16-10, my SUV oil engine light came on this time I checked the oil and no oil in the motor put 2qts begin home speed drop75-45radiator bursted needengine. The 96-99 recall onmitsub. Mont is the samething wrong with the01'.
The contact owns a 2001 Mitsubishi Montero Sport. The contact observed an excessive amount of fuel spilling from the lower portion of the fuel tank. The failure occurred without warning. The vehicle was taken to an independent mechanic for inspection and they stated that the failure was related to the weld zone of the lower portion of the fuel tank. The vehicle was repaired, but the failure recurred on two additional occasions. The fuel tanks were replaced. The VIN was unknown. The failure mileage was 82,222 and the current mileage was unknown.
In Jan. My wife started to get a whiff of gasoline every now and then when she got out of her 2001 Montero Sport. It was not enough to arouse suspicion. In the week of 3/27/06, the smell became severe. I found gas running down the gas tank, dripping onto a hose running below it, and to the ground. I brought the vehicle to be repaired at vachon Mitsubishi on thurs. , 3/30/06. I was contacted by vachon and told that the tank was rotted at the seam and would need to be replaced. I asked if this would be under warranty as the car was only 5 years old and had 44,000 mi. Vachon informed me that it would not be under warranty. The repair would cost $1083. I called Mitsubishi to question the warranty as I have never heard of a gas tank wearing out so quickly. They informed me that it might be covered under the 7 year/100,000 mile corrosion warranty. I contacted vachon and had them look into it. It was discussed with regional management and they decided that it would not be covered, it would be part of the expired emissions warranty. I again called cust. Service. I told them that this failure was too far out of sorts to be out of warranty. Gas tanks last 20 to 40 years and this decision should be reconsidered. I was told that it would be reviewed. I was again refused. I asked that a higher level of management review the case. I was told that it would be done and someone would get back to me. 5 days later, I called back because nobody called me. I was told that the case was reviewed again and again they decided against me. My case never got to a higher level of management, it was decided by mr. Tessmer, the regional parts and service manager every time. I asked if I could speak to mr. Tessmer. The answer was no. At this point the car is fixed. It will cost me $1100. 06 to pick it up, more than the price quote. My wife and 7 year old had been complaining of frequent headaches. The headaches have subsided since they stopped using the car.