11 problems related to tank assembly have been reported for the 2004 Nissan Titan. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2004 Nissan Titan based on all problems reported for the 2004 Titan.
Tl-the contact owns a 2004 Nissan Titan. The contact stated the fuel sending unit was inaccurate and will read a quarter tank of fuel when the fuel tank was actually empty. The vehicle was taken to the dealer who stated the problem was the sending unit and there are no recalls or warranty for his vehicle. They will repair the failure but at the owners expense. The manufacturer was notified and stated there are no recalls or warranty and offered no other assistance. The failure mileage was 88,000. Mw.
While fueling, gas back flows out of inlet during first 1/4 tank. Fueling must be done at a trickle for first +- 5 gallons, or you end up being doused with gasoline.
After filling the gas tank full with gas, the fuel gauge only indicated the tank is 3/4 full. This happens very time I fill up. A fuel gauge issue could lead to the vehicle running out of fuel and leaving my family and I stranded somewhere. This is a huge safety concern.
When re-fueling 2004 Nissan Titan, the fuel spews back out the filler nozzle onto operators body. Dealer has previously replaced charcoal canister and fuel tank on 10/ 2005, 12/2005, 1/2007, but problem continues to occur.
The contact owns a 2004 Nissan Titan. Whenever the contact placed fuel into the vehicle, the gasoline would come right back out of the tank through the filler tube. The vehicle was taken to the dealer and they stated that a pressure valve needed to be replaced. The current and failure mileages were 24,800.
At 42,000 miles, my 2004 Nissan Titan started leaking fuel from the fuel tank. My Nissan dealership states that it is due to a faulty fuel sending unit and fuel tank. I have researched this topic online in forums and have found that this is a common problem with 2004 through 2007 Nissan Titans. I have made a request through Nissan corp. For a "good will repair" and have not gotten a response in three days. My vehicle has been at the dealership for eight days. The dealership replaced the fuel tank and the fuel sending unit.
I have a 2004 Nissan Titan and whenever my gas tank is low and I go to fill up after a while gas will start to gush out. I've taken it to the dealership and like always they can't "duplicate". I know other Nissan Titan owners with the same problem where gas squirts out. This is a heath and saftey issue. The gas has gushed back out at me several times. . And it happens about 30 seconds after you start pumping gas.
Gas tank "spews" gas at you when filling. The tank has been replaced and still does this. The brakes "judder" and cause the vehicle to shake. They have been repaired three times and are still not correct. Nissan refuses to admit this is a significant safety issue. There are technical service bulletins on the brakes.
Numerous problems have arisen with my leased 2004 Nissan Titan king cab. Including serious vibration problems that occurred upon braking to the point the vehicle was parked until the dealer finally agreed to at least 'turn' the rotors. Eventually brakes were replaced by dealer 6 months after the initial problem. Currently facing problems including a noise at startup that everyone can hear except the dealer mechanics, an overflow problem with gas tank even though just a few liters have been put in an empty tank. Additionally major problems with driver side door refusing to open from both the inside and outside. Dealer has realigned door numerous times but problem continues. Dealer states the door problem is due to a poor design with a heavy door on inadequate hinges. Occasionally have had to drive while holding door closed. Extremely dangerous considering weight of door. This truck is barely one year old and problems just keep piling up with little dealer support offered.
Gas flies out of gas tank when filling empty tank at cooler temperatures. Even at low flows the gas splashes out of the gas tank 2-3 feet in a projectile manner spilling gas onto the vehicle , pavement and person pumping the gas. Vehicle is a 2004 Nissan Titan crew cab 2wd truck.
The consumer refuels the vehicle by placing the pump handle in the fixed position. After about 2 gallons of fuel has flowed into the tank fuel overflows onto the ground.