There have been 5 safety recalls for the Nabi 60LFW. The most recent recalls are shown below. Table 1 and Table 2 show the historical recalls and the recall statistics by the model year of the Nabi 60LFW.
This could result in loss control of the bus increasing the risk of a crash. This could also result in a loss of electrical power and engine controls. This loss of electrical power and engine controls may render the vehicle stalled in a roadway. Additionally, the floor inside the vehicle will become uneven posing a risk to passengers in the vehicle.
| Recalled Vehicles: 2005 Nabi 60BRT, 2006 Nabi 60BRT, 2007 Nabi 60BRT, 2003 Nabi 60LFW, 2004 Nabi 60LFW, 2007 Nabi 65BRT |
| Component: STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS |
| Recall Summary: Nabi is recalling 579 my 2005-2007 60brt model year 2007 65brt and my 2003-2004 60lfw transit buses. These buses may contain a defective welded crossmember assembly in the understructure. This crossmember is a welded assembly that includes a steel channel welded to the articulated joint casting at ... Details of this recall 🔎 |
During long term operation involving repeated flexing of the drag link, it may eventually crack and break. The driver will no longer have steering control of the vehicle and a crash could occur causing injury or death.
| Recalled Vehicles: 1998 Nabi 35LFW, 1999 Nabi 35LFW, 2000 Nabi 35LFW, 2001 Nabi 35LFW, 2002 Nabi 35LFW, 2003 Nabi 35LFW, 2004 Nabi 35LFW, 2005 Nabi 35LFW, 1998 Nabi 40CLFW, 1999 Nabi 40CLFW, 2000 Nabi 40CLFW, 2001 Nabi 40CLFW, 2002 Nabi 40CLFW, 2003 Nabi 40CLFW, 2004 Nabi 40CLFW, 2005 Nabi 40CLFW, 1998 Nabi 40LFW, 1999 Nabi 40LFW, 2000 Nabi 40LFW, 2001 Nabi 40LFW, 2002 Nabi 40LFW, 2003 Nabi 40LFW, 2004 Nabi 40LFW, 2005 Nabi 40LFW, 1998 Nabi 45CLFW, 1999 Nabi 45CLFW, 2000 Nabi 45CLFW, 2001 Nabi 45CLFW, 2002 Nabi 45CLFW, 2003 Nabi 45CLFW, 2004 Nabi 45CLFW, 2005 Nabi 45CLFW, 1998 Nabi 60LFW, 1999 Nabi 60LFW, 2000 Nabi 60LFW, 2001 Nabi 60LFW, 2002 Nabi 60LFW, 2003 Nabi 60LFW, 2004 Nabi 60LFW |
| Component: STEERING:HYDRAULIC POWER ASSIST SYSTEM |
| Recall Summary: On certain transit buses, the front axle stops and the power steering gear hydraulic limit valves were found to be out of adjustment. The drag link may experience permanent deformation due to the steering load. ... Details of this recall 🔎 |
In the event of a crack the clamps could break off affecting toe-in and alignment. The tie rod can come loose resulting in steering loss and a crash could occur without prior warning.
| Recalled Vehicles: 2004 Nabi 40LFW, 2004 Nabi 60LFW |
| Component: STEERING:LINKAGES:TIE ROD ASSEMBLY |
| Recall Summary: Certain transit busses equipped with tie rod clamps, heat treatment of clamps created a surface hardness that could lead to a fracture of the clamps. ... Details of this recall 🔎 |
When this occurs, the driver will be subjected to hard turning of the steering wheel and loss of power assist in the steering system, increasing the risk of a crash.
| Recalled Vehicles: 2003 Nabi 40LFW, 2004 Nabi 40LFW, 2005 Nabi 40LFW, 2003 Nabi 60LFW, 2004 Nabi 60LFW, 2005 Nabi 60LFW |
| Component: STEERING:HYDRAULIC POWER ASSIST:POWER STEERING FLUID |
| Recall Summary: On certain 40' and 60' transit buses, the hydraulic system that provides power to the radiator cooling fan and power steering system is subject to becoming unstable. ... Details of this recall 🔎 |
During an emergency situation, the first emergency egress window located on the curb side of the vehicle, immediately behind the entrance door, will not open sufficiently to allow a person to escape in the event of an emergency, which could cause personal injury or death.
| Recalled Vehicles: 2003 Nabi 60LFW, 2004 Nabi 60LFW |
| Component: STRUCTURE |
| Recall Summary: Certain transit buses fail to comply with the requirements of federal motor vehicle safety standard no. 217, "bus emergency exits and window retention and release. " there is interference between the side destination sign and the window frame that will not allow the window to open sufficiently. ... Details of this recall 🔎 |
| Date | Component | Vehicle Affected |
|---|---|---|
| Apr. 21, 2009 | Structure: Frame And Members:underbody Shields | 579 |
| Mar. 9, 2005 | Steering:hydraulic Power Assist System | 3,680 |
| Feb. 15, 2005 | Steering:linkages:tie Rod Assembly | 178 |
| Oct. 1, 2004 | Steering:hydraulic Power Assist:power Steering Fluid | 690 |
| Jul. 22, 2004 | Structure | 153 |
| Model | # Recalls |
|---|---|
| 2005 Nabi 60LFW | 1 |
| 2004 Nabi 60LFW | 5 |
| 2003 Nabi 60LFW | 4 |
| 2002 Nabi 60LFW | 1 |
| 2001 Nabi 60LFW | 1 |
| 2000 Nabi 60LFW | 1 |
| 1999 Nabi 60LFW | 1 |
| 1998 Nabi 60LFW | 1 |