Four problems related to power window have been reported for the 2003 Saturn ION. The most recently reported issues are listed below.
2003 Saturn Ion . Consumer writes in regards to vehicle recall issues the consumer stated the vehicle was purchased new and she was never informed of a recall regarding the body control module which she was having problems with. The consumer stated the problem first started when the driver side window dropped when she closed the door. Then it would not stay up. Then half of the dash went black. The next window would go up and down on its own with no contact of any type. Then the controls to the electric windows stopped working completely and the electronic lock/opening device would not open the doors any longer or lock the trunk. The consumer was informed she would have to pay for a diagnostic test. The consumer also stated there was also a problem with the transmission. The vehicle did not react to being in park, so therefore, she had difficulty removing the keys from the ignition. The O2 sensor and the ignition switch had to be replaced. The consumer stated the transmission was never properly replaced. On one occasion, the vehicle stalled and the steering locked up.
2003 Saturn Ion 1. During cold weather the passenger side window frosts. The controls are set for defrost, air on and blower medium high. Even with the blower on high there is very little air coming from the passenger side defrost outlet. A CO-worker has a similar problem with his Ion. The dealer said the system is operating as designed. 2. The hood latch freezes and the hood cant be opened to add window washer fluid. Sometimes you can get the hood open but you cant relatch the hood completely without pushing the hood release handle down. A CO-worker has a similar problem with his Ion. 3. Some the edges on interior plastic parts on the are very sharp. The worst is the compartment door to the left drivers leg. This popped open and had a sharp rough edge. As I exited the car I cut my leg. I fixed this myself by filling the edge.
The driver's side door leaks at the top. Condensation gathers on the upper inside of the door and drips on the drivers leg, as well as on the power window/locks switches, which could cause corrosion or a short in the electrical system.
Consumer having problems getting two recalls performed on the vehicle. When the consumer tried to make an appointment, the dealership told the consumer he had heard of the recall but was not familiar with what it said, the consumer wanted to make an appointment for the weekend, but was told the most skilled mechanics worked weekdays. The consumer felt the dealership had only been minimally informed of the recall.