Engine And Engine Cooling Related Problems of the 2005 Saturn ION

Table 1 shows nine common engine and engine cooling related problems of the 2005 Saturn ION. The number one most common problem is related to the engine and engine cooling (16 problems). The second most common problem is related to the car stall (five problems).

Table 1. Engine And Engine Cooling related problems of Saturn ION

Problem Category	Number of Problems
Engine And Engine Cooling problems	16
Car Stall problems	5
Engine Shut Off Without Warning problems	3
Check Engine Light On problems	3
Engine problems	2
Engine Stall problems	2
Engine Failure problems	1
Gas Recirculation Valve (egr Valve) problems	1
Engine Grinding Noise problems	1

Recently reported Engine And Engine Cooling problems of the 2005 Saturn ION

The Engine And Engine Cooling problem

The contact owns a 2005 Saturn Ion. The contact stated that while driving approximately 55 mph, the loss motive power without warning. The contact stated that steering assist and gauges were in operable. The contact coasted to the side of the road and restarted the vehicle. Read details...

The Car Stall problem

The contact owns a 2005 Saturn Ion. The contact stated that while driving at approximately 25 mph, the vehicle stalled without warning. The vehicle was able to restart. The failure occurred on three occasions. The vehicle was not diagnosed or repaired. Read details...

The Engine Shut Off Without Warning problem

We bought our 2005 Saturn Ion used sept. 4, 2012,(87,812) before even could take off lot they had to install an ignition cylinder and cut new key, and the throttle was stuck could press all the way to floor, and would only get up to about 20mph. This was also fixed. (or so we thought). Read details...

Engine And Engine Cooling related problems in other Saturn ION model year vehicles:

Switch Make:

Switch Model:

✿ Fuel Economy of ION Vehicles

☘ ION Service Bulletins

⚑ ION Safety Recalls

☤ ION Defect Investigations