One problem related to brake disc pads has been reported for the 2006 Saturn Relay. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2006 Saturn Relay based on all problems reported for the 2006 Relay.
I was traveling on az state route 87 on a 6 percent downgrade. I had applied the brakes a total of 3 times for no more than 3 to 5 seconds at a time, this occurred over a 5 minute time frame. On the third application the brakes began to cavitate very badly. This caused the vehicle to sway and brakes faded out. The brakes made a rubbing sound for the next several days. When brakes are applied while turning they make a grinding sound/feel. The vehicle was taken into Saturn of arrowhead peoria, az on 07/06/06. They stated nothing was found wrong with brakes. They said it is common for brakes to fade on this vehicle going down hill. They stated we should downshift to compensate. They can not explain why brakes make sound while turning, they say brakes are fine. I personally believe problem is that brake rotors are to small for size of vehicle. That they heat up to quickly and fade out and rotors begin to warp. This is a design flaw that can be corrected by increasing rotor size and brake shoe size, there is plenty of room in wheel well.
| Service Brakes problems | |
| Brake Disc Pads problems | |
| Brake Sensor problems |