Headlights Problems of Saturn Relay

The contact states there was an ongoing problem with exterior and interior lighting. While driving, the headlights and the dashboard panel lights flickered from bright to dim. Also, the idle was very loud and rough. She took the vehicle to the dealer. The dealer replaced the alternator. This did not correct the problem. The dealer was unable to accurately diagnose the problem, and no further repairs were made. Updated 12/27/2005. The horn springs were deform which resulted in the horn being inoperative. The sliding door would chime as if the door was not closed. The tech adjusted the top middle and bottom latches. The brakes pulsated when braking. The technician had to resurface both front rotors.

See all problems of the 2005 Saturn Relay 🔎.

Headlights flicker even after 5 repair attempts. Heater intermittently inoperative after 5 repair attempts. Power sliding doors do not close properly after 4 repair attempts. Difficult starting after 3 repair attempts. Fuel gauge erratic below quarter tank.

Headlights, dash lights and interior lights go dim/bright/dim/bright etc. At night when acceleration with foot or with use of cruse control. Notified Saturn and also dealer. They both said this is a characteristic of the Relay. Dealer also said they had the same proiblem with the l series. Saturn nor dealer have attempted to talk directly to me or fix it despite e-mails, letters, phone calls. I worry that an 18 wheeler might think I am flashing him that it is ok to pull over to the right. This is a dangerous situation and the new 05 Saturn Relay should not have been released for sale to the public if they had the same problem last year with the l series. Check "mycarstats. Com" for same complaints on the l series.