Tank Assembly Problems of Saturn Relay

Saturn Relay owners have reported 3 problems related to tank assembly (under the gasoline fuel system category). The most recently reported issues are listed below. Also please check out the statistics and reliability analysis of Saturn Relay based on all problems reported for the Relay.

1 Tank Assembly problem of the 2005 Saturn Relay

Failure Date: 10/15/2006

: the contact stated when the vehicle was facing down hill moving or parked, with 1/4 of a tank of gas or less, the fuel gauge indicator needle would move toward empty and fuel would not flow to the engine causing a problem starting the vehicle. Also, this caused the vehicle to stall while the vehicle moved down hill. The sales/service dealer and manufacturer were notified, and the contact was informed by both the service dealer and the manufacturer, that the design of the vehicle required at least a half full tank of fuel to prevent engine failure. Updated 1/19/2007 -.

See all problems of the 2005 Saturn Relay 🔎.

2 Tank Assembly problem of the 2006 Saturn Relay

Failure Date: 05/13/2006

2006 Saturn van is designed with the characteristic of running out of fuel when operating on an incline (nose up or nose down), with a 1/4 tank of fuel remaining. After this occurred the 2nd time I complained to the dealership and asked them to repair. They stated they were aware of the characteristic and that it could not be repaired. They cautioned me to not allow the gas level to drop below 1/2 tank. They stated this was listed as a characteristic of the car in the owners manual and that released them from responsibility.

See all problems of the 2006 Saturn Relay 🔎.

3 Tank Assembly problem of the 2005 Saturn Relay

Failure Date: 04/21/2005

Purchased 2005 Saturn Relay to get better gas mileage than previously owned yukon @ 11 mpg, after in depth discussion with lafayette la. Saturn dealership salesman about the reason for new car purchase. Asked if the sticker info of 18 mpg (with a stated range of 15-21) city was reliable. I was adamantly assured that it was. After first 22 gallons used, yielded app. 12. 6 mpg- this vehicle had app. 2600 miles at time of purchase. I asked for another Relay after app. 2 wks and first tank of gas, (20 gallons) yielded 11. 9 mpg. Saturn tested the vehicle by driving 20 miles in traffic and filled tank again x 2 and got app 16-17 mpg. I stated that this testing did not replicate using almost an entire tank of gas. They recorded my gas mileage after the next fill up, I drove a few days in the city going app 163 miles and used 13. 798 gallons, yielding 11. 8 mpg. The local dealership recommended I take the problem to the Saturn corporation customer service. Saturn customer service assured me that the documentation of my complaint would be passed on the appropriate parties but there was nothing that could be done for me.


Other Common Gasoline Fuel System related problems of Saturn Relay

Problem Category Number of Problems
Tank Assembly problems
3
Fuel Delivery problems
2
Gasoline Fuel System problems
2


Fuel Economy of Relay Vehicles
Relay Service Bulletins
Relay Safety Recalls
Relay Defect Investigations