12 problems related to rear suspension have been reported for the 2004 Saturn VUE. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2004 Saturn VUE based on all problems reported for the 2004 VUE.
Tl-the contact owns a 2004 Saturn Vue. The contact was driving approximately 5 mph when a loud bang was heard. The vehicle was maneuvered to the shoulder of the road, but the contact could not locate the failure. The contact continued to drive and noticed that the steering wheel was difficult to control. The vehicle was again maneuvered to the shoulder of the road where the contact noticed that the rear passenger wheel was detached from the frame. The vehicle was not taken to have the failure diagnosed nor repaired. The manufacturer was made aware of the failure, but offered no assistance. The failure and current mileages were 85,000. Kmj.
The contact owns a 2004 Saturn Vue. While driving approximately 35 mph a loud noise was heard and the rear passenger side tire began to shake. The contact was able to drive the vehicle to his residence. Upon examining the rear passenger side tire it was bent. The vehicle was towed to an authorized dealer where both the rear toe links were being replaced because a bolt sheared off. The failure and current mileages were 116,000.
2004 Saturn Vue rear suspension causes wheel to collapse due to shearing of bolt under constant load. This problem spurred a voluntary gm recall in 2004. My vehicle had the recall work completed. In August, 2009, the wheel collapsed again while my wife and kids were in the car. I'm not sure how they drove it home with that condition without a rollover or accident. I had the repair made free of charge after much argument but am concerned that in 4-5 years, bolt fatigue will cause the situation to repeat once again. I have the sheared bolt head in my possession . I am writing due to concern that many many others will again, soon, this year, experience the same wheel collapse after having their voluntary recall repairs made in 2004. It seems like a mandatory recall of the gm voluntary recall is in order. Excerpt from consumer affairs article, August 5, 2004: general motors is voluntarily recalling the Saturn Vue to fix a problem with the rear suspension. In doing so, it may be hoping to avoid litigation that could result from accidents occurring while government safety agencies conduct their own investigations. The recall affects 246,433 Vues in the 2002-2004 model years, including 231,123 in the united states and 15,310 in canada. It all started when a Saturn Vue owner wrote to the national highway traffic safety administration (NHTSA) to complain that the rear wheels of his car collapsed on a tight turn, causing the vehicle to roll over. The agency decided to conduct a test of its own, taking tight turns at 45 mph, and sure enough, the rear suspension collapsed and the car rolled over. The same thing happened when a two-wheel drive model of the Vue was put through the same test. . Read more...
2004 Saturn Vue rear suspension causes wheel to collapse due to shearing of bolt under constant load. This problem spurred a voluntary gm recall in 2004. My vehicle had the recall work completed. In August, 2009, the wheel collapsed again while my wife and kids were in the car. I'm not sure how they drove it home with that condition without a rollover or accident. I had the repair made free of charge at the dealer after much arguing but am concerned that in 4-5 years, bolt fatigue will cause the situation to repeat once again. I have the sheared bolt head in my possession. I am writing due to concern that many many others will again soon, this year, experience the same wheel collapse after having their voluntary recall repairs made in 2004. It seem like a mandatory recall of the 2004 gm voluntary recall is in order. Excerpt from caug 5, 2004 onsumer affairs article: general motors is voluntarily recalling the Saturn Vue to fix a problem with the rear suspension. In doing so, it may be hoping to avoid litigation that could result from accidents occurring while government safety agencies conduct their own investigations. The recall affects 246,433 Vues in the 2002-2004 model years, including 231,123 in the united states and 15,310 in canada. It all started when a Saturn Vue owner wrote to the national highway traffic safety administration (NHTSA) to complain that the rear wheels of his car collapsed on a tight turn, causing the vehicle to roll over. The agency decided to conduct a test of its own, taking tight turns at 45 mph, and sure enough, the rear suspension collapsed and the car rolled over. The same thing happened when a two-wheel drive model of the Vue was put through the same test. . Read more...
2004 Saturn Vue with 18,938 miles. The vehicle was sitting in my driveway when I heard a very loud bang. I thought someone threw a rock at my car. I failed to find reason for noise until I drove my car out of the driveway. When I pulled out, the rear end was very loose, swaying from side to side, and it felt like there was no control. Returned to my driveway and found a washer laying on the ground. The loud noise I heard must have been a bolt(s) that sheared, while the car was just sitting. Took vehicle to dealer where they determined that both bolts for the lateral links were broken and twisted. Tech replaced both rear lateral links and set toe.
2004 Vue multiple issues. . . First issue less then 100 miles on vehicle, depressed brakes car continued to creep at stop sign. Diagnostics at Saturn dealership: split in brake line, replaced under warranty. Second issue: less then 300 miles on vehicle, quick stop caused rear seat safety harness to become disconnected from vehicle wall. . Daughter was not restrained and slid forward in seat. Saturn diagnostics: someone was not doing their job the day it was made. . . They tightened screw back into wall of car and have not had issues since. . . This was uncalled for and should have been caught during safety inspection. Third issue: saw details on news about recall on this model of Vue, contacted Saturn dealership about it and was told that we would be getting information in the mail about repairs. Fourth issue: about 20,000 on Vue, went to store and was functional, came out and car would not start, over half a tank of gas in vehicle and gauge shows empty, bought gas can and put 5 more gallons of gas in car. Still shows empty and car would not start, no word on reason for failure beaches it happened today (10/23/05).
In the past year, I have already had to repair the rear suspension twice, the front suspension, my back seat latch, and my rotors. My Vue is the worst vehicle I have ever purchased. When driving in any bad weather I have no traction and slip all over the road.
While driving 60 mph and switching lanes rear wheel turned inward, causing the rear suspension to fail. As a result, the vehicle lost control and crashed into a guard rail. Upon impact, airbags deployed.
Vehicle was recalled, and it will be 45-60 days before the part will be available, they will send her a letter. Manufacturer stated to consumer that they did not have to do recall repairs on the . Suspension seal. They were not forced to do this, and would not do it on their own.
Vehicle was recalled, and there will be 45-60 days before the part will be available, they will send consumer a letter. Manufacturer stated to consumer they did not have to do recall repairs on the . Rear suspension seal. They were not forced to do this, and they would not do it on their own.
My son was driving my 2004 Saturn Vue on Monday, July 26, he apparently hit a patch of gravel which caused him to lose control. When he attempted to regain control of the vehicle it went into the ditch on the opposite side of the road where the passenger side rear wheel collapsed and the vehicle overturned. There is extensive damage to the vehicle on the front end and passenger side, as well as to the shift casing inside the Vue from when my son's knee slammed into it. The vehicle is still being estimated for insurance purposes (either to total it or repair it).
I was involved in a car accident on July 14, 2004 while in my 2004 Saturn Vue front wheel drive. I was hit on the rear passenger tire area and the back tire bent under the car and my Saturn was tipped over and spun around with the drivers side down on the pavement. This was not a high speed accident. I was probably about 20miles per hour and the person that hit was probably between 25-35mph. My Saturn Vue sustained about $10,500 damage some of which was the rear suspension. I do not yet know of the final outcome with the insurance whether it will be repaired or totalled. I just happened to read the kansas city star today 7-27-04 abiyt tge government safety agency investigating the Saturn Vue and this fit the description completely.