general problems of the 2020 Subaru Forester - part 1

My son, [xxx] is currently driving this car. The car only has 29,200 miles so far. Last week, while at the stop light on the hill, he had near fatal accident! Forester suddenly completed shut down. The only functioning part was the brake. My son had to put the car in park and restart the engine. I reported the incident to customer advocate at Subaru and taking the car in for inspection. We never skip any scheduled maintenance. My next maintenance not due until April. I also purchased Subaru safety monitoring software. The car never shows any malfunction. It’s a very serious issue. We strongly suspect it’s related to the start-stop system on this car. We strongly support to override the system at consumer level giving their unreliability. Thank you for your attention to this matter. Sincerely, [xxx] information redacted pursuant to the freedom of information act (foia), 5 u. S. C. 552(b)(6).

While driving my 2020 Subaru Forester at approximately 15 mph, the engine unexpectedly shut off, resulting in an immediate loss of propulsion (vehicle stall while in motion). This created a safety risk because the vehicle was in traffic and could have been struck from behind or lost the ability to accelerate out of danger. No crash occurred and there were no injuries. There were no warning lamps, warning messages, check engine light, or limp mode before, during, or after the stall event. The vehicle later experienced catastrophic engine failure, also without any warning indicators. The vehicle has been inspected by an authorized Subaru dealership. The dealership confirmed the failure and diagnosed crankshaft bearing failure on cylinder 3, and recommended short block replacement along with related engine component replacement (including cam phasers and gaskets/seals). The engine/vehicle remains available for inspection upon request. Manufacturer has been notified through Subaru of America customer advocacy. Subaru has offered partial goodwill assistance but has declined further escalation or full remedy. Note: I have video of this showing no engine lights however unable to upload it below. Can send via email if required. Thank you. [xxx] information redacted pursuant to the freedom of information act (foia), 5 u. S. C. 552(b)(6).

2020 Subaru Forester periodically will stall out at a light or stop sign in heavy traffic. It then takes several attempts to restart. (sometimes completely dead) my mechanic hasi changed the battery and checked the alternator, all in working order. It’s hard to figure out what is wrong because it doesn’t happen all the time.

When stopped at an intersection the car stalled. It would not restart for three minutes and caused a dangerous situation for my family and children in the car while traffic was moving. There were no warning signs, lights, or engine codes. The problem is random and cannot reproduced. The car is available for inspection.

We were traveling in rural California, 1 hour north of bishop, CA on CA-120 when our vehicle's "check engine" light, "parking break" light, and several other lights lit up on our dashboard. Our car began to stall out immediately. We were able to pull off to the side of the road as best as we could as we were towing a camper at the time as well. We waited for 4 hours to get our vehicle and camper towed 1 hour away to a mechanic. The mechanic couldn't fix our car, but we were able to get an engine code reader to clear the codes as they came up. The closest Subaru dealership was 4 hours away in las vegas, nv. We had to drive through mountains and death valley. Despite using the engine code reader to clear codes every 30 seconds, our car stalled out 6 times on the way. The problem was the thermo control valve for p26a6, a known problem with Subaru vehicles like ours. We had our vehicle serviced in July 2025 for 60,000 miles and the dealership did not say anything about this known issue.

I, the owner of a 2020 Subaru Forester am writing to you in regards to an issue with my vehicle’s eyesight program. Over the past month, there have been several instances where the eyesight program fails and caused the vehicle to suddenly stop without warning. This prevents me from safely moving the vehicle to the side of the road as the car stops. In other words, the car abruptly stops on the spot. This creates an immediate danger to life and health to myself and to other motorists. This issue must be addressed immediately and the necessary steps taken to ensure the safety the driver, passengers and other motorists on the road. Thank you for understanding.

The contact owns a 2020 Subaru Forester. The contact stated that while his wife was stopped at a red traffic light in the middle lane and surrounded by other vehicles, the auto start/stop system engaged; however, when the brake pedal was released, the vehicle failed to restart. After several attempts, the vehicle eventually restarted, allowing the driver to safely pull over. There were no warning lights illuminated. The vehicle was towed to the local dealer, where it was diagnosed with a dead battery. The dealer advised the contact about turning off the auto start/stop system. The battery had been marked as good on two separate occasions. The battery was replaced. The contact reached out to the manufacturer, who opened a case but confirmed there was no warranty coverage on the vehicle. The manufacturer referred the contact to the NHTSA hotline to report the failure. The failure mileage was approximately 36,585.

Parasitic battery drain.

I was stopped at a red light and the engine stalled. It read "for safety, auto restart disabled". All warning lights on the dashboard lit up. I had to put the car in park and restart it in order to drive. I was honked at and put in a dangerous position. This has happened at least twice now.

My Subaru suddenly had numerous warning lights go on. Took it to the dealer and they said it was due to a recalled part: thermo control valve. They replaced it for free but said my head gaskets needed to be replaced after checking my oil for $4000 plus. I believe the recalled part caused the head gasket issue and shouldn’t have to pay also the mileage is only 66k.

Periodically, the vehicle stalls at stop lights, stop signs, and in other situations when coming to a complete stop. Once the vehicle comes to a complete stop and turns off due to the auto-stop/start function, it stalls immediately after the car re-starts and you press the gas pedal. This leaves the vehicle stalled in intersections and in potentially dangerous conditions. You must engage park and restart the vehicle while stopped in the middle of traffic, which poses a significant safety risk. I believe this issue is related to the auto-stop/start functionality. The vehicle has been inspected by a Subaru dealer several times, but they claim they cannot reproduce the problem and there are no diagnostic codes or warning lights. No other mechanic has inspected the vehicle.

My Forester just totally shuts down sometimes from the auto start feature in traffic or intersections . Errors come up . The wheel locks and I must put the car in park , turn it off and turn it back on. Very scary and very dangerous.

Subaru Forester engine stalls at an intersection due to auto start stop feature of Subaru to save fuel, except that this is the second time when engine is idling it lowers the revs and then it stalls when trying to auto start engine; first time the dealer said is battery issue, I replaced the battery at my cost, and this is the second time. It is dangerous because there are oncoming traffic and I have only a split second to turn on my flashing lights. This is a brand new battery install on 9/2024.

"check engine" light along with "eye sight" appeared suddenly on Nov. 22, 2024. All safety systems along with cruise control became inoperable. Took car to Subaru dealer and it was confirmed to be the catalytic converter. My VIN is covered under extended warranty, but I was never notified of this. Plus, now repairs are of an emergency nature. Also, I do a lot of driving including on the NJ turnpike, I-95, etc. , and while I am awaiting car to be repaired, I have no safety features to rely on--which was one of the reasons I bought a Subaru. They will not pay for a courtesy car loan. Another issue is the thermo control valve. I was notified that I have an extended warranty for this, but part has to fail before Subaru will make repairs. Once again this becomes an emergency repair situation instead of a proactive one.

Upon exiting freeway, all lights on car came on including brake light. When placed in park, the engine would rev. If placed in drive, car would drive without gas given. Car towed to Subaru dealership and diagnosed with thermo control valve defect which seems to be a known widespread issue. Thankfully I was located close to a Subaru dealership however if not, this could cause others to be stranded. Given this widespread issue, a recall should occur to fix this issue.

Vehicle traveling w on [xxx] bryan TX. Automobile suddenly started shaking and not developing power, driver was able to pull off on the shoulder barely clearing the #2 lane. The engine would crank but not sustain operation. The auto required transport to the home garaging location. Subsequent analysis of the fuel showed it to be gasoline, no water, lacked appearance of any foreign matter. With the ignition on 12v were detected at the gas tank terminal, however the in tank pump would not produce fuel flow at the connection at the top of the tank. Had the vehicle been operating in the #1 lane it may not have been possible to clear the traveled lanes thus causing a traffic safety problem. A state trooper did provide protection until the vehicle was transported. Information redacted pursuant to the freedom of information act (foia), 5 u. S. C. 552(b)(6).

Car shuts off while stopped at light. This has happened 3 times. I have taken it to Subaru service provider and keep being told nothing is wrong. Car must be put into park and restarted to work. It is unsafe. There are multiple reports online ([xxx] and [xxx] ) of people reporting the same issue. Information redacted pursuant to the freedom of information act (foia), 5 u. S. C. 552(b)(6).

Within one month the same thing happened. I turn on the car and the eyesight warning light is on (eyesight feature disabled), flashing "s" drive is on, "break" light is on, and check engine light is on. Due to this cruise control isn't working. My plan was to take it to a mechanic/dealership that Monday. By Monday morning, after about 15 minutes of driving, all warning signs disappeared. This exact thing happened a few weeks later (this morning). I started googling issues and seems like this is an issue for many customers and is just a malfunctioning thermo control valve, no actual problem. What do I do about this? this is much less important - but also seems like a quality issue, at drivers side, the seat cover is starting to crack, looking like this is car is over 10 years old, we've had it for less than 4 years and this shouldn't be happening on a car of this caliber. Photos attached.

The contact owns a 2020 Subaru Forester. The contact stated while driving 70 mph, the vehicle failed to accelerate and then stalled. The driver was able to pull over safely. There were no warning lights illuminated. The vehicle was towed to an independent mechanic, who determined that the failure was due to the thermal control valve and produced dtc codes: p2682 and p26a. The mechanic replaced the cooling gasket and coolant control valve and added coolant. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and assisted with the repair. The approximate failure mileage was 52,395.

P2682 engine overheating and engine gauge flashing red due to a recall related to the engine coolant bypass valve. The vehicle stopped and required a tow for $417 to the nearest Subaru dealership to repair. After towing to the dealership they charged 31% of parts to labor and would not eliminate or discount the invoice.

The contact owns a 2020 Subaru Forester. The contact stated while driving at 60mph,a deer jumped in the roadway causing damage to the front driver-side engine compartment. No air bags had deployed. The contact had managed to pull onto the side of the road. The contact stated she and the front passenger exited the vehicle safely when shortly afterward a fire started in the front driver-side engine compartment. No injury was sustained. A police report was filed but was unavailable. The local dealer was not contacted, and the vehicle was not diagnosed or repaired. The vehicle was towed to a tow lot where it was then taken by the insurance company. The contact stated the insurance company had the vehicle in their possession for an investigation. The origin of the fire was unknown. The manufacturer was made aware of the failure. The failure mileage was approximately 23,000.

Defective thermostatic control valve- this part needs to be recalled. Manufacturer has extended the warranty on the part, so it was free to replace. Otherwise, it's a $1600 part. I'm thankful they covered the price, but upset that this known issue is preventable and they've been letting people continue to be put in danger for four years now?! incident 1) I was driving 45 mph on a busy street when the car bucked & all engine lights turned on (not helpful to pinpoint a problem) eyesight turned off (when I needed it most. ) the car was worse than dead. I was desperate to get to the shoulder, so I slammed on the emergency lights. Horrified, I realized turning the wheel did almost nothing. I had to lean on the steering wheel to get to the shoulder. When I applied gas it would choppily accelerate, so instead I let the car coast. Since I had no gas, I was stuck in the middle of a side road. I put it in park and turned it off. Someone started walking up from the bad neighborhood, wanted me to get out so he could push the car. I said no, but it took a few minutes to talk him into leaving through the glass of my window. But, this time when I started it up the dash warning lights were off incident 2) between oct& Nov 2024 intermittently all the dash lights turned on, no cruise control or eyesight. Resolved on its own. No engine trouble acompanied these. Incident 3) Nov 5th, 2024. I started my car, warmed it up, and drove for about 3 minute's when all the dashlights lit up, eyesight failed, and the whole engine acted like it was on choppy seas. This was at night in a rural area and I was barely able to guide the car to the right shoulder because the accelerator was not working at all. Ended up slashing up my tire and ruining my rim on the shoulder of the road since the car was barely maneuverable. I could have been killed or in an accident - where is the recall on this part?? mileage at total failure : 46,434.

I was driving to work and many of my warning lights suddenly came on. This includes my check engine light, my lane assist light, my auto collision braking, my eye sight disabled and my cool engine light keeps going on and off. My cabin heating also isn’t working. There is no reason for this happening other than my thermo control valve failing.

The thermo control valve is faulty and renders the vehicle non-operative. There have been numerous instances in Subaru Foresters in the same make and year.

The thermal control valve failed on my car and it’s only 3 years old. This is a common issue and is widely known within the forums. Subaru should recall these valves as they are failing prematurely.

I was at a red light when the engine shut off and the check engine and several other warning lights came on. After multiple tries I was finally able to restart the vehicle and drive it off the road. After taking it to the dealership the confirmed issue is the thermal control valve. The dealership is requesting about $1600 to replace the faulty part.

I stopped at a red light. The car's auto shutoff feature turned the car off for the fuel savings. When the light turned green and I went to go, the car tried to start and failed. I had to put it in park and start the car manually.

The thermo valve leaked into connector, causing engine to shut down abruptly to prevent overheating. This happened at 70 mph on interstate highway in traffic. Part was replaced with modified thermo valve later. Barely able to coast to narrow shoulder flanked by deep ditch, with vehicle very close to interstate traffic, so much so that exit from vehicle ill-advised. After towing, vehicle was serviced by Subaru dealer. At time of part failure many warning lights & messages appeared, but not before the event.

On Sunday, February 11, 2024 we were traveling in our 2020 Subaru Forester on a trip from minnesota to florida for a vacation. Not long into cross country trip we found ourselves stranded on the side of the highway uncertain about the ability of our vehicle to continue to due to a defective thermo control valve failure. About 200 miles into our trip, while driving at highway speeds south of rochester, mn the dashboard lit up. The check engine light was on, and other safety features were lit up on the dash as disabled (eye-sight technology, lane assist, automatic vehicle collision braking). The heat would not work after this incident. We checked the owners manual, and then drove to an auto-parts store to have a scan done to determine the error code. The code "p26a3 - engine coolant bypass valve a range/performance" was indicated. In checking online we discovered that a thermo control valve replacement was needed ASAP and to continue driving the vehicle could risk severe engine damage. Since it was a Sunday, and we were essentially stranded if we couldn't use the vehicle. We continued on, stopping and checking the engine periodically for overheating. We were able to get an appointment at lou fusz Subaru in st. Peters, mo on Monday afternoon and they replaced the thermo control valve at a cost of $1,961. 51. We were told that this wasn't under warranty due to the mileage on the vehicle (76,358 miles). In researching this issue online, we found that the thermo control valve failure to be a common issue and certain year/model vehicles and Subaru should have recalled this part a long time ago (in our opinion).

My thermo value went bad on my 2020 forrester with no symptoms or warning causing me to become stranded in the middle of an extremely busy road. This is seemingly known problem and I'm unsure why Subaru has not been more proactive with this knowledge, not allowing others to end up in the same dangerous situation I was left in. Also, even after having the thermo value replaced, I have no way of knowing if any permanent damage was caused to my engine.

Started engine after parking and check engine light came on, eyesight disabled, and flashing “s”. Stopped driving and took vehicle to dealer. Diagnosed as thermo control unit. Told they didn’t have a loaner and was safe to drive for a few days. Has no heat and engine would not warm up. No safety systems. Retained 3 days later to dealer when loaner was available. Repaired under powertrain warranty.

The thermal control valve stopped working. The car has <50k miles on it. The error also results in many/all of the safety systems being deactivated (no adaptive cruise control, no lane centering, no rear braking, etc. ).

I started the car to make a trip to town to run some errands. When I cranked the engine the check engine light came on. The s for sport mode was flashing and a no eyesight warning came on. Also srs side airbag light came on to indicate it was not working. And another light came on showing a car going out of its lane, but I don't know if it was the lane keep assist light or not.

Driving my 2020 Subaru forrester on 1/26/24, at night. Stopped at traffic light. Car started shaking, dash lights system lights came on. Turned off car and restarted. Car would not accelerate. Had towed to mechanic. Diagnosed as probable thermo regulator. Could not repair because part only available from Subaru. Called dealer who was not sympathetic or helpful. Told to bring in and leave. Would get to it when they could.

Check engine light came on along with eyesight, traction control and flashing [s] lights. Dealer confirmed that the thermo control valve failed.