Two problems related to brake disc pads have been reported for the 2005 Suzuki Aerio. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2005 Suzuki Aerio based on all problems reported for the 2005 Aerio.
I purchased my Aerio 2005 Suzuki Dec 2004, in Nov 2005 tires worn prematurely on 10,503 mileage, front brakes pads and rotors has to be replaced. I took car to dealership:replaced pads, mashined rotors and aligned/replaced one tire. Month later I come back to dealership with the problem to stop the car on the speed 15ml/h: push the brakes pedal to the floor, car did not stoped. Mechanik drive car, check the brakes and said brakes working fine as it is has to work as abs system, but my car does not has abs system. Sep. 2006 I did inspection with change oil service. Result of inspection the same as was in Nov 2005: alignment, tires worn out, brake pads and rotors need to be replaced and it is after 7,000 ml I add after the first replacement. Dealership algned and balance, replaced one tire again, about brakes declined, said is not warranty issue. My car has only 18,000 mileage and 100,000 warranty. Brake system is failed and alignment cost the tires primature worn out.
In middle of nigh,t no weather problems, and without warning the brakes failed. Had to stand on brakes, and had to pull emergency brake to stop. And when he got out he saw the front drivers side wheel well was glowing and smoking. Both manufacturer and dealer said it was not a defect. Caller followed maintenance routine. Dealer found the brake pads were bad.
| Brake Disc Pads problems | |
| Brake Disc problems | |
| Brake Disc Caliper problems |