Table 1 shows one common seat belt related problems of the 2022 Tesla Model 3.
| Problem Category | Number of Problems |
|---|---|
| Seat Belt problems |
The contact owns a 2022 Tesla Model 3. The contact stated that while operating the vehicle the front driver's seat belt warning chime had become inoperable and did not alert the driver that the front drivers seat belt was not secured while driving. The cause of the failure was not yet determined. The local dealer was notified of the failure and a service appointment was scheduled. The manufacturer was not contacted. The failure mileage was 35,400.
Passenger safety restraint failure message came on so I made an appointment and took it to pleasanton Tesla for repair 3/19/25; was under the 60,000 safety warranty. Then on 5/6/25, 6 weeks later, the passenger safety restraint failure message appeared again. I contacted pleasanton Tesla and they told me I was now responsible for a different piece to be replaced, which was quoted over $1,000 to repair, as the 60,000 mile safety warranty was up and it is a different piece that needed to be replaced. I said it’s the same message, passenger safety restraint failure!.
Passenger safety restraint system fault error appears on and off without any correlation to driving conditions or passenger presence. This error is potentially deadly since it will cause the passenger airbag not to deploy in an accident.
We received a front passenger safety restraint system fault on our car. When a passenger sits in the seat the fault is not displayed. This was not a software update and the sensor was faulty and could cause the airbags not to go off. The sensor was faulty in the seat but because we were out of warranty we had to pay for the repair. Clearly they have seen this issue and said it was not a recall but a bulletins and bulletins were a caution, they made us pay for the repair.
* front passenger safety restraint system issue - sensors under passenger seat intermittently failing for months even after taking it in for service. * safety of passenger is at risk as airbags might not fire due to occupant classification system failing. * service center said nothing looks wrong even though car alerts multiple times per drive. Many reports online of alert rcm2_a636 . * has been inspected by service center * alert from car beeps every 30 seconds to 1 minute intermittently, has been occurring for months.
The passenger seat belt no longer latches. The mechanism that pushes out the pin to hold the belt in is no longer working.
Car has a passenger safety restraint fault, got quote to replace a sensor for $455 parts and labor. When reading online, this appears to be a common failure in these vehicles and if you don't get repaired, air bags / seat belt restraint may not work properly. Seems like should be a recall for this.
The driver side seatbelt isn’t clicking and locking into place. Making the vehicle completely unsafe to drive.
The seat weight sensors are failing in my 2022 Tesla Model 3 long range. ” multiple sensors are malfunctioning including the seat/seatbelt & forcing the car to stay on/act occupied. In addition, if the seat is unoccupied and unbuckled - safety warning & systems are triggering- and I have no idea what type of behavior this may cause (preventative breaking/accident prevention). I am concerned for my safety due to this seatbelt system malfunctioning.
The rear middle seatbelt in my telsa Model 3 is stuck. Somehow it got stuck behind the middle seat after the seat was put down to put long items in the trunk. Tesla mobile service sent a tech to my house but he alleged intentional misuse - as if me or my family intentionally were playing with a seatbelt and wrapping it around a seat. Furthermore, even if we were to assume intentional misuse was correct I have 2 questions: 1 - why is the top of the seat belt (where the seat belt comes out of the seat) unable to be pulled to create any slack? 2 - why does telsa need to replace a part if the seatbelt, or seatbelt mechanisms, are not defective? after searching online this seems to be a somewhat common problem with Tesla - especially the Model 3, at least as early as 2021 - both on reddit and Tesla motor club forum - this seems to be a recurring problem. How does one know it cannot get stuck while driving or while someone is buckled in and cannot be released or have any slack? this is a major safety issue.
The car continuously complains about front passenger safety restraint system faults. This has gone on and off since about 15k miles and car is now at 50k miles. Tesla has said it is software related at one point (different software complains about it differently) and most recently installed an occupant classification system filter module without it resolving the issue. Now they are saying that it needs an $1100 repair. From boards and forums this seems like a well known issue that many cars are having from Tesla and it seems they are avoiding properly handing the issue and fixing it at their expense. This issue seems to cause the passenger airbag to disable and turn off when there is a passenger actively sitting in the front passenger seat as well as it makes a chime and distracts the driver every time it flips its state - which can be multiple times a minute!.
When seat is wet or damp (from a wet water bottle or sweat), passenger restraint light comes on and system is confirmed to not work properly when that happens.