Table 1 shows one common wheel related problems of the 2024 Tesla Model Y.
| Problem Category | Number of Problems |
|---|---|
| Wheel problems |
The rims on this car are made so cheap it’s no way I should have this many crack and bent rims I been thru a total of 5 rims already and Tesla don’t offer u the rim protection until u replace a rim no matter how slow I drive my rim always seen to get cracked or bent on rail road tracks or even driving over a speed bump or going thru car wash.
I have had this car since may 2024 and the current mileage on the vehicle is 7,130 miles. In the past few weeks, I have had to completely replace both rear oem aluminum alloy wheels due to cracks caused by normal road driving, which caused both rear tires to go flat. Per Tesla, this costly replacement is not covered under their warranty. I am now learning that this is a common issue with these particular wheels on this particular model (model y performance). It appears the aluminum alloy wheels are simply not sturdy enough to bear the weight of the vehicle and the required tires simply do not provide sufficient cushioning to prevent wheel cracks resulting from normal wear and tear/road driving. Many customers have had to replace the oem wheels with aftermarket wheels made of forged steel. These customers report zero issues with the much stronger wheels. This appears to be a product design or manufacturing problem, which is creating a significant consumer/public health risk.
I purchased a 2024 Tesla Model Y and received delivery of my Tesla vehicle on [xxx], at 4 pm est. Upon receiving the vehicle, I noticed manufacturing defects on the tail lights, which I reported to Tesla support immediately and scheduled an appointment on September 29. Unfortunately, no appointments were available at that time, and my service date was postponed to October 28, 2024. On [xxx], while traveling at low speeds, the rear passenger tire of my vehicle unexpectedly exploded. They are the factory-installed continental tires 255/45/19. The car had to be towed to Tesla in coral gables, where they installed a temporary tire and quoted me $517. 35 for replacement—despite the vehicle being less than a month old. Since delivery, I’ve also observed that my tail lights have accumulated water, indicating a potential safety hazard and manufacturing defect. I have contacted Tesla support on multiple occasions, but they have not provided clear guidance on whether a loaner vehicle will be provided while these issues are addressed. The lack of timely and effective support for these escalating defects has been extremely frustrating and concerning. Primary concerns: safety hazards related to the tire explosion and water accumulation in the tail lights. Delays in service appointment scheduling. Lack of clarity and support from Tesla regarding service procedures, such as whether a loaner vehicle will be provided. Given these issues, I am requesting assistance from the NHTSA in addressing the quality and safety of this vehicle, as these defects and delays are affecting my ability to operate it safely and reliably. Thank you for your attention to this matter. [xxx] [xxx] [xxx] information redacted pursuant to the freedom of information act (foia), 5 u. S. C. 552(b)(6).
My Tesla (dark gray) was t-boned by a 2015 Hyundai (white) while it was passing the intersection on green light. The Hyundai hit my car when it tried to turn right on red light. My car was running at around 25 mph at that moment. About one second before the accident, my car's front collision warning went off, but everything was too late; the Hyundai's left front bumper hit my car. The crash did not cause any serious damage on the white Hyundai; as you can see in the photo, it barely got any dents, except its left front headlight cap was broken. The incident created small dents on my car's right fender panel and front right door. However, even though my car's front right wheel was not directly hit, it fell off during the accident. If my car was running at a high speed, it would have rolled over and caused serious injuries.