43 problems related to suspension have been reported for the 1999 Toyota 4Runner. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 1999 Toyota 4Runner based on all problems reported for the 1999 4Runner.
Tl - the contact owns a 1999 Toyota 4runner. The contact stated that while reversing from a parking space, the contact heard a loud popping noise. The contact mentioned that after inspecting the vehicle, he noticed that the rear end trailing arm was detached from the frame. The failure was caused by corrosion. The vehicle was taken to the dealer. The technician advised that they were unable to perform any repairs to the vehicle however, they did take pictures of the damage and sent them to the manufacturer. The manufacturer was made aware of the failure but did not offer any assistance. The vehicle was not repaired. The failure and current mileage was 284,000. Kmj.
The rear axle seals repeatedly fail on this vehicle, I'm now having to make a fourth costly replacement of both the rear axle seal and contaminated brake shoes. For the fourth time the rear axle seal has failed which leaks brake fluid onto rear brake shoes, resulting in severe reduction of rear braking power. Also, as a result the front brakes are placed under undue pressure and warping of front brake rotors occurs which must also be addressed. While I have previously filed complaints over this same issue since 2005 with both Toyota and the nhtsb, there has been no recall initiated. The last time my rear axle seals were replaced was less than 20,000 miles ago. This vehicle only sees normal wear and usage. I am not the only complaint as many others have experienced the same issue based on Toyota forum discussions and a search of nhtsb complaint filings. Toyota customer service center again refused to assist me in any way with todays complaint filing on 7/31/12.
Tl- the contact owns a 1999 Toyota 4runner. The contact stated that the vehicle was taken in for brakes and it was discovered that the right rear and left rear of the frame had rusted. The contact stated the right was worse then the left and they were told the vehicle was unsafe to drive. The contact spoke with the manufacturer and was told there was no recall for the frame and nothiing that could be done. The failure mileage and current mileages were 225,000. Rl.
Frame rusted to the point where it broke. When it happened it almost caused a major accident. Left the vehicle in a condition that is very dangerous to drive. This vehicle has high miles but is in excellent condition otherwise. No rust anywhere on the vehicle except for the frame. Toyota is aware of the problem. I've seen the same problem with other 4runners.
Full blown frame rust mechanic states is 100% invasive affecting steering, alignment, braking, and checking of differential and rear-end fluids due to seized components. Frame is totally compromised, needs to be recalled and rectified.
Bad frame rot. Not safe to drive anymore.
Frame rotted out prematurely.
Consumer states steering wheeel vibrates between 50 and 60 mph. Consumer has had vehicle aligned, and new tires and the problem is still occuring. The vibration slows or stops when vehicle is put into 4 wheel drive. The front has been aligned twice, before and after the tires. Consumer had the exact same problem with a 1996 Toyota tacoma. This situation now causes the entire vehicle to vibrate at the same speed between 50 thru 70 mph.