Table 1 shows one common equipment related problems of the 2026 Toyota Corolla.
| Problem Category | Number of Problems |
|---|---|
| Equipment problems |
Vehicle emissions out of the dashboard defroster vents deposit a sticky, chemical film onto the inside front windshield, causing severe driver vision impairment. The chemical vapor triggers immediate respiratory irritation and dizziness, presenting an imminent risk of a motor vehicle crash. Defect / nonconformity: the vehicle suffers from a severe hvac or interior component material failure causing toxic off-gassing. An official Toyota fts report (ro #116504) documented dangerous tvoc levels of 9. 455 mg inside the vehicle. The manufacturing defect substantially impairs the safety, use, and commercial value of the vehicle. I did not have car seats in trunk, the time completed on report is changed, they will no longer inspect car. Specialist (fts) report explicitly logs tvoc levels at 9. 455 mg (3 ppm) inside the cabin. The film on my front windows is not coming from the trunk this is a known hazard . Literally told you.
I also wanted to add the mold. . From the hour test was performed on this car. Ac in high flow. Within 12 hrs growth appears.
I have mcas/ cirs this new car triggered chest pain, muscle weakness, swelling, etc fts report confirmed high off gassing. I'm in 3 mast cell stabalizers a day. I'm w out a car I put down 3500 a month ago. They left me, knowing all this. I'm 9 miles from a bus stop, from shopping, can't make money w out a car. 40 min from drs. I already have lung nodules. Single mom, just want a safe reliable car odi xxx, [xxx] information redacted pursuant to the freedom of information act (foia), 5 u. S. C. 552(b)(6).
My brand-new 2026 Toyota Corolla le is venting toxic chemical, burning plastic, and acetone-like fumes directly through the dashboard hvac vents and interior materials. Exposure to the cabin air causes immediate, severe systemic injury, including acute respiratory distress, throat and vocal cord inflammation resulting in a lost voice, uncontrollable sweating, and severe neurological muscle weakness. I have a critical pre-existing medical condition consisting of two lung nodules, making this chemical inhalation an immediate, life-threatening hazard to my health. This exposure has previously left me physically incapacitated for five days. The manufacturer (Toyota motor north America) has been formally notified of the defect and my documented medical injuries. However, the manufacturer is refusing to provide emergency alternative transportation or safe loaner transport and is delaying the vehicle safety inspection for a full week (until June 29). The vehicle is currently parked and completely undriveable due to the active chemical or thermal hazard it presents to vehicle occupants.
System or component that failed: heating, ventilation, and air conditioning (hvac) / climate control system. Description of incident: the vehicle's hvac system emits a severe, persistent chemical odor / volatile organic compound (voc) smell directly into the passenger cabin. Nail polish remover, burning plastic after driving forth 20 min, was not addressed. This toxic-smelling odor causes immediate physical discomfort, chest pain, neck stiffness, including headaches and respiratory irritation while driving, creating a driver distraction and safety hazard. Dealer status: the vehicle was taken to a Toyota dealership on June 13, July 29th, refused any further investigation. Under warrantybut the defect could not be permanently resolved by the service center. Now seeing the chip in car was messed with after getting it towed back.
I traded in my 2022 Corolla le for a 2026 Corolla se and I got my car on December 19th, 2025 and ever since I got it, the wireless charger hasn’t been working not once. I turn it on, it charges and the light is green and after a few seconds, it stops charging and flashes orange repeatedly. I tried it with different phones, without a case, and brought it to the dealership where they replaced the wireless charger but the issue continued with the new charger, so they put back the original one. The dealership told me it’s a defect issue and that other people had similar issues.