general problems of the 2006 Toyota Highlander Hybrid

I found some info in a forum where multiple people have the same complaints about leaking around the axle. I was informed that the right axle seal needs replacement when I took my vehicle to the dealership for a multi-point inspection. I'm not sure if this is something that happens over time but it seems like it's happened to others who have noticed it before the warranty expiration and it was covered under the powertrain warranty. I purchased an extended warranty but it has expired and I was never told about this issue while my vehicle was under warranty.

While driving on a major highway and in the fast lane going approximately 75/80 mph my 2006 Toyota Highlander Hybrid died and failed to drive. The panel on the dash had a red ! exclamation point, and said check hybrid system and check vsc system. I was able to navigate my vehicle to the right breakdown shoulder to call for a tow. Tried to start my vehicle several times and it would not start, but the hazard lights and instrument panel continued to light giving evidence my new 12v battery was functioning properly. Called Toyota motor USA and asked what recalls they have listed for my vehicle and they asked for my VIN. They told me the electrical inverter assembly was covered for my VIN. They gave me the number of a tow company to call and told me it was covered by Toyota and I'd have a rental waiting for me. I had it towed to my local dealership as directed, they fixed several other recall issues but not this one, so when I drove off the lot the car died again. I managed to start the vehicle and drive it back across the highway into the dealership. After speaking with Toyota corporation USA again, they apologized and said they misinformed me and that my vehicle was not part of that recall. However, they paid for my tow and for my rental for 5 days (thus far). My case number given from Toyota corp is 1607053248. I read online there is a class action suit regarding this issue. Karl and irina gaal vs. Toyota motor sales, u. S. A. , inc. , a California corporation. Via atty mike arias. Toyota's customer experience has put in a request for me to speak with a supervisor and the Toyota dealership's gm in my area is also working on this issue as it's still pending.

My wife and I were travelling on I-95 (southbound) towards richmond, va. My wife was the driver. We were steadily travelling at a speed. . . Between 65 and 70 in the left lane (required speed limit). All of a sudden, with no warning, the panel lights started blinking and the power to the car was shut off. My wife was screaming because she was not able to control or effectively apply brakes. She tried and pulled car off the road barely and we pushed it off to a safe side. This could have resulted in a serious accident if we were travelling in the middle lane. The car was left overnight and towed to Toyota dealer. The dealer called back and gave a quote of $10000 because the hybrid inverter have to replaced. I mentioned the recall on the inverter. The dealer said the recall does not cover my issue. There is a recall on your website -what action or recourse do I have. The original owner of the car replaced the inverter at 16200 miles. Evidently all the 2006 inverters are defective. My question is this ---why your department is Toyota to get away with such a serious defect?.

My wife was driving the car home after grocery shopping and the car just quit. She coasted to the side of the road and called me. I arrived and tried to start the car with no luck. Finally called a tow truck and had it towed to the Toyota dealer. They inspected the car on Tuesday (Sep 17,2013) and said the inverter was bad and that a replacement would be $8,500. I asked them to check recalls etc. . . With the regional rep. They are awaiting a small part to see if that will cause the inverter to work properly. My biggest concern was the car just quit without warning while driving down the road!.

Hybrid inverter failure. Accelerating from stoplight to enter highway ramp. Loud bang and all lights on dash came on. Engine continued running but no propulsion. Had it towed to dealer and informed it was a hybrid inverter failure, and would cost $10,000 to repair. We are now looking at class action lawsuits.

My son was driving and the vehicle stopped on him in the middle of the road with no warning or power steering. Vehicle had to be towed to the dealership. Was informed by the dealership that the hybrid generator had shorted and needed $7,300. 00 worth of repairs. I am very concerned that this vehicle is dangerous, if he was on a very busy road and this vehicle were to have stopped on him as suddenly as it did that day he could of possibly been rear-ended and seriously injured. This vehicle has been a part of several recalls with this same type of issue, but Toyota has refused my request for this vehicle to be repaired or issue a recall with this issue.

As I accelerated from a stop at a side street to enter highway traffic, I was nearly rear ended by a large truck when the hh inverter failed. The car simply suddenly failed to respond with no advance warning. Several dashboard symbols lit up, including check hybrid system,�and I was only able to steer to side of the road. It would not restart and was towed to the dealer. The dealer checked for recalls and said there were none. I mentioned the June 2011 notice we'd received, and that we were told that the part would not be available until Jan. 2012. We did not receive more information from Toyota and called the dealer in Jan. For an appointment. After a brief inspection, we were told the part was not defective and no replacement necessary. � we had been extra cautious and limited the use of our hh for months, and were disappointed that there was no effort to examine the part earlier or verify the conditions of use of the vehicle. After the car was towed in April 2012, the dealer said we needed a part, which they ordered and installed at no cost to us within a few days. The manager said that it was a very expensive part, took a long time to install, and that we were "lucky to have the warranty. "� there was no mention of the inverter recall but the invoice indicated that there was a "boj recall. " there may have been an earlier clue: on Dec. 1, 2011 the same dashboard indicators (check hybrid system and vrc) lit up in the morning when I went to start it and couldn't. We asked dealer about recalls, mentioned the upcoming scheduled notification (Jan. 2012), but were told there were none, and that problem was the battery. This may or may not have been related, but I wonder if the dealership ever considered the inverter issue in its analysis. This 2006 hh had only 25,259 miles at time of failure, only 1 owner, and rcvd regular maintenance from dealer.

While driving my 2006 Highlander Hybrid in seabrook texas on March 5, after accelerating to approximately 40 miles per hour. The car lost all power and the power steering went out. The car then had to be towed to dealership. It looks like there is an investigation open into this issue. Nhtsa # pe11005.

While driving the vehicle up a slight incline in the street after driving about 10 miles, it suddenly stopped moving. The engine was still on but the car would not go forward or backwards. The message on the dash was first check csv (or vsc) and then check hybrid system. The police had to push the car out of the intersection and the car was hauled to the Toyota dealer. I have not heard from them in 6 days what the problem is.

Driving in 6 lanes of heavy traffic we heard a 'thunk' and lost all power. I wrestled the vehicle to get it to coast off of the road. Car was towed to Toyota dealer where it was found that the inverter needed to be replaced. Cost was $7600, after a substantial discount from the dealer, who was obviously embarrassed about charging so much for a single part. The incident could have caused an accident, since all power and electrically assisted driving functions failed simultaneously. Fortunately it didn't. Subsequently I found that Toyota had upgraded their inverters beginning in 2007. We have also received in 2011 from Toyota an "interim safety recall notice" for the inverter, but have heard nothing since.

(2006 Toyota Highlander Hybrid) pulling onto 4 lane (2 lanes divided by concrete barrier) highway merging into 55+ mph traffic. Accelerated to about 30-35 mph and heard a "clunk". Car started to coast without any acceleration (gasoline engine still running). Unfortunately this was at a complicated intersection where several roads intersect without room for a shoulder. I was able to drift to the right most lane, where entering traffic from intersecting road used. I was left stranded without any control over forward movement. The repair cost is in excess of $18,000. Apparent need for a complete replacement of the hybrid system (inverter and drive system). The "blue book" value might be in the $15-16,000 range.

While driving at speed on the highway the inverter/converter failed the vehicle was coasted to a stop on the highway shoulder. Now again on 04/28/2011 with 88,856 miles on the vehicle the same failure has occurred while acceleration up-hill on the highway at about 40 mph. Most of the damaged components (inverter/converter & an ecu) where covered by warranty. I am very concerned about the safety of this vehicle and my wife continuing to drive it even though it has been repaired again.