Headlights problems of the 2007 Toyota Tacoma

The orange bulb in the headlights burnt through plastic casing inside the headlight. One side has cracked. I'm not exactly sure when this happened, but I did notice it a while back that the bulb was burning the plastic, however, I just noticed that it cracked on one side.

2007 Toyota Tacoma double cab with daytime running lights. The orange plastic lens material has cracked and burned due to the excessive heat from the bulb. The effects were noticed around 60,000 to 70,000 miles. Running headlights during the day to avoid having running lights on.

The contact owns a 2007 Toyota Tacoma doublecab. The contact noticed that the daytime running lights were melted and fractured. The dealer did not offer any assistance since there were no recalls. The manufacturer was not notified of the failure nor was the vehicle diagnosed or repaired. The current mileage was 70,000. The approximate failure mileage was unknown.

The contact owns a 2007 Toyota Tacoma. The contact stated that there was excessive corrosion on the frame where the wiring of the vehicle was located. Additionally, the headlights flickered while driving at different speeds. The manufacturer was made aware of the failure. The vehicle was not repaired. The approximate failure mileage was 8,000.

2007 Toyota Tacoma 4 dr. 4x4:the low beam headlights are designed with only illumination on the lower part of the roadway blocking short distance, night time visibility with a black line and dangerously limiting reaction time. When going down an inclined roadway that approaches an uphill change in the cartway, there is no opportunity to see more than thirty (30) yards in front of the vehicle due to a distinct loss of visibility created by a shield in the headlight lens assembly directly in front of the lamp bulb. There was no consideration given to driving on hilly roads when this headlight was designed. One would never have enough reaction time to avoid hitting a pedestrian or animal, even driving at thirty (30) mph due to the very dark line in the headlight system created on low beam only. There are many times when one cannot drive just with the high beams. This is a very dangerous design and presents a very serious night time safety visibility issue. Toyota should recall these vehicle from 2005-2007 to replace the headlight assembly before someone is killed. I have never seen such an engineering blunder that was not known during daytime test drives. Updated 01/07/08. Updated 12/12/07.