Table 1 shows one common service brakes related problems of the 2024 Toyota Tacoma.
| Problem Category | Number of Problems |
|---|---|
| Service Brakes problems |
After having Toyota Tacoma rear brake hose recall performed at steven Toyota harrisonburg va I have very poor braking! this is a huge safety concern for my family and myself. Toyota is not taking this matter seriously. I was told “bring it in and let the tech have another wack at it”. No get a master tech on this problem immediately! I had reservations about having this recall performed by Toyota because in Toyotas pursuit to fix a problem they always make it worse. This has been our family’s experience over the course of many years. I have reported this issues to Toyota corporate and they are oblivious to our families safety concerns. They are more concerned about their protocol.
What component failed?? the rear brake system (rotors and pads) and the components associated with safety recall 25ta04 (rear brake hoses). The parts are available for inspection. * how was safety put at risk? ?the dealer (island Toyota, st. Croix) labeled my 2024 Tacoma "unsafe to drive" on invoice #[xxx] but refused to perform the federal safety recall (25ta04) for rear brake hoses unless I paid for an $800 brake job first. This violates federal law by making a safety recall conditional on customer-paid maintenance. I am currently driving a vehicle the dealer documented as "unsafe" because they withheld the free safety remedy. * has the problem been confirmed?? yes, the dealer confirmed the rear brakes are failed but refused the recall and the 36,000-mile warranty claim. * has it been inspected by others?? not yet. However, the dealer’s technician failed to record actual millimeter measurements for the pads or rotors on the official invoice. * warning lamps or symptoms?? metal on metal grinding noise from the rear brakes. No warning lamps appeared prior to the failure. * additional note on records:? the dealer falsified my service records on line c (recall 25tc07), claiming I was "unwilling to wait" for a repair that was never even mentioned to me. The dealer also claims I denied service on line b, but what actually happened is I refused to pay $800 for a premature brake failure that should be covered by my 36,000 mile warranty or as consequential damage from the recall. The dealer then used my refusal to pay for pads as an excuse to withhold the federal safety recall (25ta04). I never denied the safety repair I denied a bill for a factory defect. I have uploaded photos of both rear wheels. The left side is healthy, but the right side is completely destroyed with deep scoring. This uneven wear at only 34,613 miles proves this is a manufacturing defect, not my driving style. Nformation redacted pursuant to the freedom of information act (foia), 5 u. S. C. 552(b)(6).
The contact owns a 2024 Toyota Tacoma. The contact received notification of NHTSA campaign number: 25v058000 (service brakes, hydraulic). The contact stated that while her son was driving at an undisclosed speed, the brake pedal was depressed but traveled down to the floorboard. The brake warning light blinked, and the message to “pull over to a safe area” was displayed. The vehicle was coasted to the side of the road. The contact stated that brake fluid had leaked from the vehicle. The driver was able to drive back to the residence. The vehicle was then towed to the dealer, where it was diagnosed andit was determined that there was a hairline crack visible, and that the clip on the brake line was missing a bolt. However, the dealer informed the driver that the failure had occurred due to the oversize tires installed on the vehicle. The vehicle was not repaired. The vehicle was towed back to the residence. The vehicle remained at the house unrepaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 58,000.
The contact owns a 2024 Toyota Tacoma. The contact stated that the vehicle was taken to the local dealer for recall service related to NHTSA campaign number: 25v058000 (service brakes, hydraulic). While driving at 15-30 mph, the vehicle lost braking function and crashed into a tree. After the failure, the low brake and the low brake power message were displayed. The driver had not sustained any injuries. The occupant in the passenger seat sustained spinal injuries and neck irritation; medical attention and surgery were provided. There was no reported fire, police report filed, or air bag deployment. The towing company was contacted, who informed him there was brake fluid on the driver-side rear brake line. The vehicle was towed to his residence. The next day, it was towed to a body shop. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The insurance company informed him that they would inspect the vehicle. The failure mileage was approximately 8,644.
I’m filing this report because the dealership where I purchased and have my vehicle regularly serviced failed to notify us of an active safety recall related to the brake system on our Toyota truck. The dealership is classic Toyota – located at 2301 w Mercury blvd, hampton, va 23666. The recall was issued in February 2025, yet the vehicle has been serviced by the same Toyota dealer multiple times since then, including an oil change and a state inspection. The dealer never mentioned the open recall or offered to repair it. I bought the truck prior to the recall in July of 2024. We only learned of the recall recently through the Toyota app, not from the dealership. This is unacceptable given that brake recalls pose a serious safety risk. I am requesting an investigation into this dealership’s failure to notify or perform the recall repair as required by federal law.
See attached document for complaint. I am writing to formally notify you of a serious unresolved safety issue regarding my leased 2024 Toyota Tacoma (VIN: xxxxxxx), currently subject to the official safety recall (NHTSA recall no. 25v-058 / Toyota recall no. 24ta04 - interim notice 25tb04). Despite repeated attempts to schedule the recall service with Toyota of orlando, no effective remedy ha been provided to date. The recall documentation clearly states that the defect can cause brake fluid leakage and a potential loss of braking ability, significantly increasing the risk of crash. As a parent of a t, I cannot safely operate this vehicle under such circumstances. The inability of Toyota to resolve this urgent safety defect in a timely manner not only violates consumer trust but also places my family at unacceptable risk. Therefore: I. I demand immediate confirmation of when and how the recall repair will be completed. 2. If Toyota I unable or unwilling to promptly resolve this issue, I will be forced to escalate the matter through legal counsel, including seeking termination of my lease contract without penalty. 3. I am also notifying all relevant government agencies. Including NHTSA of Toyota's failure to provide a timely and safe resolution. Attached are copies of the recall notice, service invoices, and related communications for your record . I expect a written response within 10 business days from the receipt of this letter.
After coming to a complete stop, vehicle will start to creep forward. If not paying attention, collision with vehicle in front will occur.
The contact owns a 2024 Toyota Tacoma. The contact received notification of NHTSA campaign number: 25v058000(service brakes, hydraulic); however, the part to do the recall repair was not yet available. The contact stated that while reversing at 5-7 mph and depressing the brake pedal, the vehicle failed to respond, accelerated unintendedly, and crashed into an unoccupied parked vehicle. The other vehicle sustained damage. There was no injury sustained. The contact was able to drive away from the scene. A police report was filed. The vehicle was taken to the dealer to be diagnosed, but the vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 13,652.
Checked by htn auto shop at 800 n western Ave, oklahoma city, ok-73106. Shop owner said it could be a problem sooner or later since the car is operated under dirt road a lot and recommand me not driving it very often. However I drives a lot, to go to other states and also to many off roads. Average drivers drive 12k miles a year. I bought this truck 12/05/2024, today is 8/8/2025 and have already put on over 18k miles which would translate to about 27000 miles a year, I drives 2. 5 times more than others and I need my vehicle to be safe as I drive my wife and my 6 month old baby. Toyota manufacture kept saying me they wont pay directly to the rental because there is no loaner with the VIN, they said just go and rent and send them a bill later and they will review for reimburse. I spoke with fowler Toyota rental and service manager they said the recall for my car wont be avaiable till October- that is another 2 months from now. The dealership do aware this is safety recall and I should get a rental but im not comtable with Toyota may review and 2 months later rejected my rental bill for reimburse. Toyota corporate kept telling me they have to review later. First call with them on 08/07/2025- the lady told me that Toyota will definitely review and pay for the reimbursement, I just need to go rent and pay for them myself first then reimburst later. I told her I cant do that I need Toyota to pay directly and she said there was nothing she can do. Then I went to fowler Toyota trac department (rent a Toyota) at dealership and told the dealership I want to leave my truck there till recall is done and I need a rental. Fowler Toyota manager said I need to try to contact Toyota corporate again and try to have them pay directly to the dealership for the rental so I called Toyota corporate again while I was waiting at the dealership and again they refused said I need to pay upfront first and they will review for reimburse later. This time they said they "may" reimburest me later.
On July 25th 2025 the rear brake hose recall repair was performed on a 2024 Toyota Tacoma by an authorized Toyota dealership at jim norton Toyota okc. Approximately one week later, the passenger side rear brake hose began leaking a significant amount of brake fluid. This triggered the brake warning light and a “loss of braking power” message on the dashboard. The brake pedal became soft, and stopping distance increased noticeably, creating a serious risk to driver and public safety. The vehicle was unsafe to operate and was towed to a dealership. The issue was confirmed by the dealer’s service department and repaired. The incident occurred without any prior warning lamps, messages, or symptoms. The problem appears directly related to the recent recall repair, either from improper installation or premature failure of the replacement part.
Weird brake feeling.
The contact owns a 2024 Toyota Tacoma. The contact received notification of NHTSA campaign number: 25v058000 (service brakes, hydraulic); however, the part to do the recall repair was not yet available. The vehicle was taken to the dealer; however, the contact was informed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Vehicle inadvertently in 4 wheel drive mode. When turning steering wheel, in drive or reverse mode, the brakes locked up and froze vehicle in place. Barely able to maneuver vehicle by straightening steering wheel as best I could to get it to park. As I accelerated to get it to move, brakes activated against it. No alarm/notice appeared on dashboard to switch to 2-wheel mode. Tow truck driver arrived, identified problem, but was unable to get it to 2-wheel mode. Towed to santa maria CA Toyota service center. They corrected to 2-wheel mode, checked to confirm no damage, and wrote it off as driver error/lack of general knowledge.
The contact owns a 2024 Toyota Tacoma. The contact received notification of NHTSA campaign number: 25v058000 (service brakes, hydraulic); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2024 Toyota Tacoma. The contact stated that while driving at an undisclosed speed, the system malfunction warning light illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact received notification of NHTSA campaign number: 25v058000 (service brakes, hydraulic). The vehicle was taken to the dealer and the recall repair was performed. The contact stated that the failure reoccurred. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 19,168.
I have a new 2024 Toyota Tacoma that I purchased December 2024. My dashboard lit up the morning of Thursday, April 17. Drive start warning on the dashboard and a secondary breaking malfunction warning I contacted my local Toyota dealer and informed him that my vehicle is giving me warnings and I only have 13,000 miles on the vehicle. I took the vehicle and they told me that it was the fuel pump they replaced the fuel pump return the vehicle to me, and before I could leave the parking lot both codes on the dashboard shut up again and the vehicle would not move. I am writing this report to document what is going on with the vehicle. I believe that it is a lemon and there’s something majorly wrong with it. I brought the vehicle brand new in December and again it’s only has 13,000 miles on it right now.
The contact owns a 2024 Toyota Tacoma. The contact received notification of NHTSA campaign number: 25v058000 (service brakes, hydraulic); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
The contact owns a 2024 Toyota Tacoma. The contact received notification of NHTSA campaign number: 25v058000 (service brakes, hydraulic); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and opened a case. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2024 Toyota Tacoma. The contact received notification of NHTSA campaign number: 25v058000 (service brakes, hydraulic). The contact stated that the dealer was contacted; however, the contact was informed that parts were not yet available for the recall repair. The vehicle was not repaired. The manufacturer was contacted about parts availability. The contact had not experienced a failure.
I have this truck from 2024 , the safety recall came up from February 2025 . But the company not fixing this issue. I’m a rideshare platform driver . My rideshare company also remove this vehicle from their platform for open safety recall . I contacted with my dealer also the Toyota main phone number . They still not solving my issues . Please help me out I’m now job less person because of this vehicle.
The contact owns a 2024 Toyota Tacoma. The contact received notification of NHTSA campaign number: 25v058000 (service brakes, hydraulic) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
There is currently a safety recall on my vehicle that has no remedy available. There is a risk of having brake hoses rupturing and losing braking fluid, causing a no brakes situations and high risk for an accident. I reached out to the dealership and was provided with no information on how to resolve the situation, but was referred to their company's headquarters. Once I reached out to their representative, I was informed that the estimated time to provide a potential repair would be about 3 months. Essentially I was given the option of either driving the vehicle and expose myself and others to a vehicle incident or store my vehicle until there is a remedy provided, but still incur the costs of the vehicle, namely paying the vehicle loan.
The vehicle is a 2024 Toyota Tacoma sr5 that was later traded for a 2025 Tacoma sr5 due to a serious safety defect involving the rear brake lines. The problem is the same one described in Toyota’s recall: the rear brake hoses can be damaged by debris, resulting in brake fluid loss and potential brake failure. The safety risk was significant. The vehicle was used to transport a young child, and because the brake lines could fail without warning, the truck could not be safely operated for daily driving. Multiple franchised Toyota dealerships confirmed that they had no remedy parts available for several months and that the repair could not be performed. This left the vehicle without a functional safety repair for an extended period. The manufacturer’s public statements indicated that a fix existed, but dealerships consistently stated the opposite. No alternate transportation, loaner vehicle, or temporary replacement was provided during this period. The defect was not reproducible by driving because of the risk involved, but the safety issue was acknowledged by dealerships who stated that the recall was active and unresolved. The vehicle was effectively unusable for normal safe operation. No warning lights appeared on the dashboard; the hazard is related to the physical brake line design and exposure to debris rather than an electronic sensor. The vehicle was inspected by multiple Toyota dealerships, all of whom confirmed that no repair could be performed at the time. The component was not replaced, repaired, or made safe before the vehicle was traded out of due to the unresolved safety defect. The situation caused substantial safety concerns and financial hardship and appears to reflect a wider problem in remedy availability for this recall.
The contact owns a 2024 Toyota Tacoma. The contact received notification of NHTSA campaign number: 25v058000 (service brakes, hydraulic). The contact called the local dealer, who confirmed that parts were only ordered once per week, and there were nine customers ahead of him on the waiting list. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The contact had not experienced a failure.
Feb 06,2025 manufacturer recall number25tb04 NHTSA recall number25v058 recall statusrecall incomplete, remedy not yet available summary the rear brake hoses in the subject vehicles can be damaged over time if there is enough build-up of mud and dirt inside the rear wheels from operating under certain off-road conditions. Safety risk this can result in a brake fluid leak, increasing the risk of crash. Mileage is under 4k now. Truck was paid off for over $40k and I can't drive it the way intended. They have informed me once regarding the recall via email and when getting routine service the service department was aware of recall and stated to just not drive my truck in 4x4 mode. That's why I bought this truck. The 4x4 mode.
The contact owns a 2024 Toyota Tacoma. The contact stated that while shifting into gear, the vehicle jumped and continued to move. There were no warning lights illuminated. The contact received notification of NHTSA campaign number: 25v058000 (service brakes, hydraulic). The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 18,000.
Vehicle information vehicle: 2024 Toyota Tacoma VIN: [xxx] ate: January 26, 2025 repair completed: October 1, 2025 safety complaint description beginning on or about February 5, 2025, my 2024 Toyota Tacoma developed a serious braking-related safety issue that substantially affected the safe operation of the vehicle. When I brought the vehicle to the dealership, I reported braking concerns and was advised by dealership personnel that the vehicle may not be safe to drive due to concerns that the rear brakes might not function properly under certain conditions. I was specifically told by dealership staff that they would not recommend driving the vehicle due to safety risks. Despite this warning, I was forced to continue operating the vehicle because no repair remedy was available at that time and no equivalent loaner vehicle or safe alternative transportation was provided. Over the course of several months, I repeatedly contacted the dealership regarding the issue. Each time, I was told that no repair remedy was available and that nothing could be done until Toyota released a repair solution. I was also advised that my only option was to leave the vehicle at the dealership indefinitely, which was not practical because the vehicle was my only means of transportation. As a result, I was forced to continue driving a vehicle that had been identified as unsafe. The defect remained unresolved for approximately eight months. During this time, I experienced significant safety concerns and loss of reliable vehicle use. Because of the prolonged delay in repair and lack of alternative transportation, I was ultimately forced to purchase another vehicle in order to maintain necessary transportation. The braking-related condition was not permanently corrected until approximately October 1, 2025. This situation created significant safety concerns because I was forced to operate a vehicle that dealership personnel advised may not be safe to drive, yet information redacted pursuant to the freedom of information act (foia.
I approched a controled intersection with no traffic vehicle stopped on its on vehicle displayed secondary collision brake system malfuction see the dealer.
Stopping at a stop light, after coming to a complete stop, vehicle will want to slowly creep forward and you need to press a little harder on the brake pedal. If you don't pay attention, you will creep into the vehicle in front of you. I am in the transmission TSB range.
The contact owns a 2024 Toyota Tacoma. The contact stated that the gas cap failed to close securely and was loose. Additionally, the contact received notifications of NHTSA campaign numbers: 25v058000 (service brakes, hydraulic) and 25v595000 (electrical system); however, the parts to do the recall repairs were not yet available. The contact stated that the instrument panel was blank at start-up. The contact also stated that the infotainment system screen was blank intermittently while driving, which required the driver to pull over to the side of the road to turn off and restart the vehicle. The dealer was contacted several times for the recall repairs, but the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure by voicemail message. The failure mileage was approximately 80.
Hello NHTSA, I'm writing to you about a safety design concern (not a complaint, no incident happened) on my 2024 Toyota Tacoma. The rear brake lines are routed inside the wheel and have approximately 3/4" clearance. There is no room for error and brake failure may occur very easily with the line getting damage, even by removing and installing the wheel. My concern is safety for my family and self with future brake related failure. I contacted Toyota and their response was that they haven't heard of an incident and to take to the dealer. I'm sure the dealer will charge me for the visit and say there are no recalls and nothing damaged.