Table 1 shows one common other fuel system related problems of the 2004 Volkswagen Beetle.
| Problem Category | Number of Problems |
|---|---|
| Other Fuel System problems |
Driving my 2004 Volkswagen Beetle is dangerous. The tiptronic transmission in the 2004 vw Beetle is known by Volkswagen to be defective. At any point the valve body can fail, which causes delayed shifting, and hard jerking between gears. My 2004 Beetle fails to shift when accelerating between 2nd and 3rd gear. This causes the vehicle to coast for several seconds, sometimes requiring pulling off the road because of traffic. When downshifting it jerks extremely hard. You get in, start the engine, and receive no warnings that anything is wrong with the vehicle. No check-engine light provides any indication that the vehicle is dangerous. You drive down some city streets and hop onto the freeway to go to your favorite grocery store. After getting off the freeway the car is fully warmed up, and as it downshifts from 4th to 3rd gear it lurches. It feels like the engine is trying to jump out of the car! no engine light comes on. Then you stop at the end of the off-ramp, and wait for a traffic light to turn. After turning the car shifts from 1st to 2nd gear. Then it fails to shift from 2nd to 3rd gear. The gear doesn't engage, and the car coasts down the road without any power. Drivers passing by are staring. The SUV behind you is right on your butt; they begin honking. There's nothing you can do. Finally, after 20 seconds of coasting the car enters 3rd gear with a giant lurch. It feels like it's going to explode! you pull into the grocery store parking lot, heart racing, knowing that the car you're driving almost caused an accident that could kill a half a dozen people. And you know to get home it's going to happen all over again. This problem is reported by hundreds of owners. This is an extreme safety hazard. Volkswagen needs to recall the affected vehicles and pay damages for those whose transmissions were destroyed by this defective valve body and transmission.
Feul leak, rear passanger side right. Same side that the fuel fill is on.
My engine light came on and the ac stopped blowing cold air. I also noticed a beep sound that would come on when I turned the headlights on but the sound would turn off and on while I drove. Then the alarm stopped working and the interior lights malfunctioned, the radio also gave out and the vehicle seemed to hesitate while driving it. I checked the fuse box on the battery and discovered that the slot where the fuse slips into on top of the vehicle battery was melted and there was something on the driver side headlamp cover like some type of gas or fumes had escaped the battery and sprayed the headlampcover. I changed the fuses around and got the ac going again, then I changed them all out, and everything worked great for about 5 days, then the interior lights went out again, the alarm stopped working, radio is out, the beeping sound is back and when I checked the fuse, it was melting again. I am afraid that while in the vehicle with my children I will have a malfunction and be injured. I just paid off the vehicle. . . What a gift for paying off a vehicle. . . Seems like eveything in and on that vehicle is a hazard and an accident waiting to happen. . Its sad because I use to love my new Beetle.