Other Fuel System Pump problems of the 2010 Volkswagen Golf

Engine failure on road. Service is claiming it is a fuel pump issue. . . . High pressure fuel pump.

I was stopped at a red light preparing to make a left hand turn when I noticed that the engine started making a rattling noise. After the light turned green, I proceeded to make my turn and after exiting the intersection the vehicle started to hesitate and eventually stalled. I pulled to the side of the road safely and tried to restart the vehicle but it would not start. I called aaa and my local vw dealer and had the car towed there for repair. I was told that the high pressure diesel fuel pump failed and that it would be replaced as a "goodwill" by vw since my car was just out of the 5 year 60k warranty. To my knowledge, the entire fuel system was replaced with the exception of the fuel tank itself which was cleaned. Everything was taken care of by vw with no charge to me, and a loaner car was provided.

I have a 2010 vw Golf tdi. I was driving along at 25 mph when my glow plug & check engine lights started flashing, and my tachometer dropped to zero, indicating a stall. The power steering also started to cut out, but I was able to safely pull over. Tried starting the car again and got nothing. The car was towed to a vw dealership down the street, and on Monday 11/19 they informed me that my high-pressure fuel pump failed and sent metal fragments through the entire fuel system. The car is currently being repaired under warranty, but I was told that the bill would be at least $5,000 for this kind of fix. Oh yeah, this also completely ruined my travel plans for thanksgiving, as vw refused to give me a loaner car while this documented warranty issue was being dealt with. After doing some research, I found that there are several cases of 2009-10 tdi fuel pump failures with the same symptoms. Apparently, there have been three revisions of this pump since then, and I am due to get the newest one. But, there is also talk that ultra-low-sulfur diesel fuel in the us is not providing the proper lubricity, and thus causing the pumps to fail (this is not an issue in europe). Nonetheless, further investigation by the NHTSA should result in vw doing a proper recall and redesign, rather than quietly fixing an inherent flaw on a case-by-case basis. Even with my car fixed, I'll still be wondering when this will happen again. Which also makes me wonder if I should just sell it and be done with vw. Very frustrating.

Entering the freeway and a high speed, engine light and ignition coil light appeared when I reached the end of the on-ramp. Lost all propulsion 30 seconds later; the vehicle would not accelerate. Vehicle coasted to a stop on the shoulder, but barely made it since I had to move several lanes over and avoid traffic going around me. If I was moving slower, I would have been stranded on one of the lanes. There have been many other cases of the high pressure fuel pump failure for the turbo diesel engine, my vehicle is just another one.

Upon changing my fuel filter, a large amount of metal flakes were discovered in the fuel housing. They seemed to be linked to the high pressure fuel pump. Vw had to replace due to a failure starting in the high pressure pump.