Three problems related to check engine light on have been reported for the 2011 Volkswagen Routan. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2011 Volkswagen Routan based on all problems reported for the 2011 Routan.
My check engine light came on so I had the code checked it indicated that O2 sensors needed replaced then the code indicated a cylinder 4 misfire? ihave replaced the ignition coil pack, checked cylinder compression, changed spark plugs and fuel injector and I still have the po304 code engine misfire cylinder #4??? I am so frustrated what else could I be missing to clear this code issue?.
Vehicle engine would do the extended crank, and not turn over, or would turn over and die instantly, check engine light would flash 10 times. Took vehicle to the dealer to find out that the tipm module had failed, the repair was $1200, and took a week. Chrysler had built the vehicle for Volkswagen from their town and country line, however unlike Chrysler, Volkswagen doesn't honor the recall although the part is physically the same mopar part across the board. Volkswagen also stated they offer no assistance after the base warranty is gone as well. Isn't there some federal mandate that requires these devices to be warranted further than the normal 36,000 miles? I guess it will take someone getting severely injured or killed in one of these vans for Volkswagen to open there eyes. . .
My 2011 Routan suddenly lost power while I, with my kid on board, was driving on a highway in March 2014. Can you imagine a vehicle stopping in a flow of vehicles at 70+ mph? all lights were on. I managed to restart the engine and was able to drive but the check engine light was still on. The dealership from whom I bought the vehicle "repaired" it and told me that "everything is fine" by having a brand-new set of wiring. A month later, the same life-threatening issue happened again while I was driving. This time, the vehicle stalled and I could not rotate the steering wheel at all. Now the vehicle is again with the dealership for diagnosis. As a matter of fact, about half a year ago before these losses of power happened, I experienced another problem with the vehicle. The acceleration was not very responsive. That is, when I hit the gas pedal, the vehicle initially did not accelerate at all and after 2-3 seconds, it suddenly accelerated. This really frightened me as I tried to change lanes. Now I have no confidence with this vehicle at all. I am deeply worried that even if the vehicle is "repaired" this time, I and my family could get injured or killed by having a car that randomly shuts off in the midst a stream of fast-moving vehicles. This type of vehicle should be banned from the road for the safety of innocent people.