Fuel Pump problems of the 2005 Volvo S40

The contact owns a 2005 Volvo S40. The contact stated that while driving at an undisclosed speed, the vehicle stalled without warning. The vehicle was towed to an independent mechanic who diagnosed that the fuel pump electronic module had failed due to rusting and corrosion. The fuel pump electronic module was replaced and the failure was remedied. The manufacturer was notified of the failure and the contact was informed that the vehicle was not included in the NHTSA campaign number 08v033000 (fuel system, gasoline). The contact stated that the vehicle had experienced the failure listed in the recall. Additionally, the vehicle was originally sold in the state of California and had been driven in the state of michigan the past 6 years. The failure mileage was 147,000.

The contact owns a 2005 Volvo S40. The contact stated that the vehicle would stalls randomly with the illumination of the power service warning light. The contact took the vehicle to a mechanic and was told that the pump electronic module was failing and that there was a recall for the failure (NHTSA campaign id number: 08v033000-fuel system gasoline: delivery: fuel pump). The contact spoke with the manufacturer and was told that the vehicle was not included in the recall. The failure mileage was 71,000.

The contact owns a 2005 Volvo S40. The contact stated that the check engine light illuminated and the vehicle stalled while she was driving. The vehicle was taken to an authorized dealer where it was repaired according to recall 08v033000 (fuel system, gasoline: delivery:fuel pump) but the contact still experienced the same failure after the repair. The dealer also informed her that she needed to have a fuel pump sensor needed to be replaced. The vehicle had not been repaired again. The manufacturer had not been notified. The current mileage was approximately 69,000. The failure mileage was approximately 68,000. Updated 03/15/lj also, there was an internal fault with the ignition which caused the vehicle to shut down. Updated 04/28/11.

The contact owns a 2005 Volvo S40. The VIN was not included in NHTSA campaign id number 08v033000 (fuel system, gasoline:delivery:fuel pump). The contact was concerned of a failure occurring since the state of kentucky uses salt. There had been no failure to date. The current mileage was 43,000. Updated 02-19-08 updated 02/19/08.

Volvo S40 year 2004. 5 problems with engine start and engine check light coming on due to possible problem with fuel pump electronics. Recalls are only impacting certain u. S. States to have the part replaced. What about recalls for owners residing overseas under government orders?.