general problems of the 2006 Volvo S60

My 06 S60 has blown 3 charge air hoses in the exact same spot. (the hose behind the radiator. ) a golf-ball sized hole blows out in a bend in the hose while driving. The car will idle , but throttle up at all. The dealer says this is a fluke.

I have made a recent complaint regarding safety concerns with a faulty etm (electronic throttle module) on my vehicle. I dropped it off at my local authorized dealer for Volvo and I did not tell them that the car produced an error code p2135 / ecm-9200 -- throttle position sensor --faulty signal, because I wanted to see what error codes they would pull off. It is my understand even if I reset the 'check engine' light the dealer is able to pull the codes of the computer. Well in this case the dealer called me today and adviced me that no codes could be pulled but wanted to know if the person working on my car could take it home with him and take a reader. I said no, but I did not take my car there because I want something for free. I am beyond fraustrated with the Volvo because of the faulty design. What will it take next time for me to be on the freeway and driving and the error to be displayed and cause me to drop my speed down and get into an accident? I fear that day will come someday if not me someone else.

Etm fails causing me to ¿limp home¿ or has erratic throttle behavior, had repaired basically they just stated it had to be cleaned but the injectors where fine. After spending over $600. 00 dollars now they are stating I need to spend another $600. 00 on the part to replace because the motor is causing it to fail. I am usually driving down the road and then a message will display ¿reduce engine performance¿ causing me to go from 65 down to 40 miles per hour and I fear that one day it is going to cause and accident due to a mechanical failure on behalf of Volvo etm fiasco. Volvo has known this is a faulty design because back in 1999 to 2002 there was a recall and they were issued a 10 year warranty or 200,000 mile warranty after repeat failures. I am filing a complaint based on safety concerns and demand a recall and based on the same issue ¿faulty design¿ and Volvo has known this continues to be a problem. 2006 seem to have a very high repair and this so happens to be one of those cars. Thanks!.

In my 2006 Volvo S60 the etm went out after only 48000 miles. The engine has a rough idle and won't go over 40 mph. It's in limp mode. A replacement for the etm is upwards of $1,000 and the dealer needs to be the one to service to mate the etm to the car. Looking on the forums and around it amazes me how common this problem is. The recall that was for 1999-2002 models should be extended to all model years that are affected by this faulty part to ensure that all Volvo owners are safe from this potentially dangerous problem.

The electronic throttle module had to be replaced in my 2006 Volvo S60. The car only has 72,702 miles! this is after having paid several hundred dollars to have the etm cleaned several months ago. The cost to replace the etm was over $800. As I search the internet, these cars seem to have problems with this particular part. It's ridiculous to think that I'm going to have to keep paying for this part, especially when the car is only 5 years old and has far less than 100,000 miles!!! I demand a recall and warranty replacement! the service manager at my local Volvo dealership tells me these units need to be cleaned or serviced about every 30k miles. I have a copy of my receipt from this weeks service. This part should be covered under a warranty by the manufacturer! believe me, I'm active on the web and I'm going to tell everyone I know to stay away from Volvos.

The contact owns a 2006 Volvo S60. The contact stated that intermittently when attempting to start the vehicle it failed to start. The vehicle was taken to the dealer and the technician could not duplicate the failure or provide a remedy. The failure mileage was 15,000 and the current mileage was 47,000.